Resumen del contenido incluido en la página 1
GAS GRILL
LP Gas Grill Owner’s Guide
Guía del Propietario del Asador de Gas Propano Licuado - Pg. 27
Mode d’emploi du grill à gaz PL - Pg. 51
330
#54406
YOU MUST READ THIS OWNER’S GUIDE m WARNING: Follow all leak-check
BEFORE OPERATING YOUR GAS GRILL.
procedures carefully in this manual prior
to barbecue operation. Do this even if the
barbecue was dealer-assembled.
m DANGER
If you smell gas:
NOTICE TO INSTALLER: These instructions
1. Shut off gas to the appliance.
must be left with the own
Resumen del contenido incluido en la página 2
WARNINGS m DANGER Failure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manual may result in serious bodily injury or death, or in a fire or an explosion causing damage to property. m WARNINGS m Do not attempt to disconnect any gas fitting while your barbecue is in operation. m Do not store a spare or disconnected liquid propane m Use heat-resistant barbecue mitts or gloves when operating cylinder under or near this barbecue. barbecue. m Improper assembly may be dang
Resumen del contenido incluido en la página 3
TAbLe oF coNTeNTS WARNINGS.......................................... 2 mAINTeNANce ..................................... 21 CLEANING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21 ® TAbLe oF coNTeNTS................................. 3 WEBER SPIDER/INSECT SCREENS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21 BURNER TUBES CLEANING OR REPLACEMENT . . . . . . . . . . . . . . . . . . . . . . 22 eXPLoDeD VIeW......
Resumen del contenido incluido en la página 4
eXPLoDeD VIeW • DIAGRAmA De DeSPIece • VUe ecLATee Genesis_330_LP_US_080911 1 2 3 23 4 5 24 6 25 7 8 26 9 27 10 28 29 11 30 330 EP 12 31 32 13 33 14 34 15 35 36 16 37 17 38 39 18 19 40 41 20 42 21 43 44 22 45 46 47 4
Resumen del contenido incluido en la página 5
e XPLD o e D VIe W LIST • LISTA De L DIAGRAm A De De SPIe • LISTe De LA VU e LAT 1. Thermometer 17. Catch Pan Holder 33. Igniter Module Termómetro Soporte del plato recolector Módulo de encendido Thermomètre Support pour égouttoir Module de l’allumeur 2. Thermometer Bezel 18. Left Frame Panel 34. Wind Deflector Moldura decorativa del termómetro Panel izquierdo del bastidor Deflector de viento Collerette du thermomètre Panneau de châssis gauche Déflecteur de vent 3. Shroud 19. Front Frame Support
Resumen del contenido incluido en la página 6
WARRANTY Weber-Stephen Products LLC (Weber) hereby warrants to the ORIGINAL PURCHASER of this ® Weber gas grill that it will be free of defects in material and workmanship from the date of purchase as follows: Aluminum castings: 25 years (2 years on paint; excludes fading) Stainless steel shroud: 25 years Porcelain-enameled shroud: 25 years Stainless steel burner tubes: 10 years Stainless steel cooking grates: 5 years no rust through or burn through ® Stainless steel Flavorizer bars: 5 years n
Resumen del contenido incluido en la página 7
GeNeRAL INSTRUcTIoNS ® ® Your Weber gas barbecue is a portable outdoor cooking appliance .W ith the Weber STORAGE AND/OR NONUSE gas barbecue you can grill, barbecue, roast and bake with results that are difficult to ® ® • The gas m ust be tur ned off at the liquid pr opane c ylinder when the W eber gas duplicate with indoor kitchen appliances . The closed lid and Flavorizer bars produce barbecue is not in use . that “outdoor” flavor in the food . ® • W hen the W eber gas barbecue is sto
Resumen del contenido incluido en la página 8
GAS INSTRUcTIoNS SAFE HANDLING TIPS FOR LIQUID PROPANE GAS CYLINDERS • Liquid P r opane (LP) gas is a petr oleum pr oduct as are g asoline and natur al gas. LP gas is a gas at regular temperatures and pressures . Under moderate pressure, inside a cylinder, LP gas is a liquid . As the pressure is released, the liquid readily vaporizes and becomes gas . • LP gas has an odor similar to natur al gas. Y ou should be aware of this odor . • LP gas is hea vier than air . Leaking LP gas may
Resumen del contenido incluido en la página 9
GAS INSTRUcTIoNS IMPORTANT LP CYLINDER INFORMATION 5 2 4 3 m DANGER 1 ® NEVER store a spare LP cylinder under or near Weber gas appliances. NEVER fill the tank beyond 80% full. Failure to follow these statements exactly may result in a fire causing death or serious injury. 2 ® 4 Weber gas appliances are equipped for a cylinder supply system designed for vapor 5 3 withdrawal . 1 ® m WARNING: Only use Weber gas appliances outdoors in a well-ventilated area. Do not use in a garage, building,
Resumen del contenido incluido en la página 10
GAS INSTRUcTIoNS A) Open base cabinet doors . Bring regulator and hose forward out of cabinet (1) . B) Locate hose retention clip (2) on regulator hose . Secure into slot (3) on underside of 1 tank scale . 3 2 m WARNING: The hose must be secured to the tank scale with the Hose Retention Clip. Failure to do so could cause damage to the hose resulting in a fire or explosion which can cause serious bodily injury or death, and damage to property. Some LP tanks have differing top collar assembl
Resumen del contenido incluido en la página 11
GAS INSTRUcTIoNS Remove Control Knobs & Control Panel for Leak Testing You will need: Phillips & flathead screwdrivers . A) Locate door pin release in door assembly . Using a screwdriver, push down on door pin release (1) until door detaches from frame assembly . Pull top of door away from frame assembly (2) and lift door off bottom adjustable hinge pin . B) Remove control knobs, igniter button, retention nut, and battery (3) . C) Remove screws from wind deflector with a Phillips screwdriver (
Resumen del contenido incluido en la página 12
GAS INSTRUcTIoNS Check A) Regulator hose to bulkhead connection (1) . B) Main gas line to bulkhead connection (2) . C) Main gas line to manifold connections (3) . 8 D) Side burner gas line to manifold connection (4) . E) Side burner pipe fitting to side burner cup (5) . F) Side burner pipe fitting to side burner valve connections (6) . m WARNING: If there is a leak at connection (1, 2, 3, 4, 5, or 6), re-tighten the fitting with a wrench and recheck for leaks with soap and water solution. If
Resumen del contenido incluido en la página 13
beFoRe USING THe GRILL FUEL LEVEL 1 2 3 Check the fuel level by viewing the color indicator level line, located on the side of the tank scale . A) Empty (1) B) Medium (2) C) Full (3) ◆ SLIDE-OUT GREASE TRAY AND DISPOSABLE DRIP PAN Your grill was built with a grease collection system . Check the slide-out grease tray and disposable drip pan for grease build-up each time you use your grill . Remove excess grease with a plastic spatula; see illustration . When necessary, wash the grease tray and
Resumen del contenido incluido en la página 14
mAIN bURNeR IGNITIoN & USAGe MAIN BURNER IGNITION Note: Summary lighting instructions are inside the left-hand cabinet door. 5 m DANGER Failure to open the lid while igniting the barbecue’s burners, 1 or not waiting five minutes to allow the gas to clear if the barbecue does not light, may result in an explosive flare-up 2 which can cause serious bodily injury or death. 2 A) Open the lid (1) . B) Make sure all burner control knobs are turned off (2) . (Push control knob in and turn 6 it clock
Resumen del contenido incluido en la página 15
mAIN bURNeR IGNITIoN & USAGe MAIN BURNER MANUAL IGNITION m DANGER Failure to open the lid while igniting the barbecue’s burners, or not waiting five minutes to allow the gas to clear if the 1 barbecue does not light, may result in an explosive flare-up 4 which can cause serious bodily injury or death. 2 A) Open the lid (1) . 2 B) Make sure all burner control knobs are turned off (2) . (Push control knob in and turn it clockwise to ensure that it is in the OFF position .) 6 m WARNING: The b
Resumen del contenido incluido en la página 16
® SeAR STATIoN IGNITIoN & USAGe ® SEAR STATION BURNER IGNITION The 330 model includes a sear burner, which operates as an individual burner . Ignition 1 of the sear burner is the same as ignition of a main burner . To ignite the sear burner refer to “MAIN BURNER IGNITION” . Follow all steps, dangers, and warnings when igniting the sear burner as you would when igniting a main burner. ◆ ® SEAR STATION BURNER MANUAL IGNITION To manually ignite the sear burner, refer to “MAIN BURNER MANUAL IGNIT
Resumen del contenido incluido en la página 17
GRILLING TIPS & HeLPFUL HINTS ® • Alwa ys pr eheat the g r ill bef or e cooking . Set all b ur ner s on HI heat and close lid; heat When meat juices drip from the food onto the specially angled Flavorizer bars, f or 10 min ut es , or until ther momet er r egist er s 500° – 550° F (260° – 288°C). they create smoke that gives foods an irresistible barbecued flavor . Thanks to the ® • Sear meats and cook with the lid do wn for perf ectl y g r illed f ood ever y time . unique design of the
Resumen del contenido incluido en la página 18
SIDe bURNeR IGNITIoN & USAGe SIDE BURNER IGNITION The grill illustrated may Summary lighting instructions are inside the left hand cabinet door . have slight differences than the model purchased. m DANGER Failure to open the lid while igniting the side burner, or not 1 waiting five minutes to allow the gas to clear if the side burner does not light, may result in an explosive flare-up which can cause serious bodily injury or death. m WARNING: Check hose before each use of barbecue for nick
Resumen del contenido incluido en la página 19
SIDe bURNeR IGNITIoN & USAGe SIDE BURNER MANUAL IGNITION The grill illustrated may have slight differences m DANGER than the model purchased. Failure to open the lid while igniting the side burner, or not 4 waiting five minutes to allow the gas to clear if the side 1 burner does not light, may result in an explosive flare-up that can cause serious bodily injury or death. A) Open the side burner lid (1) . B) Check that the side burner valve is turned off (2) (Push control knob in and turn c
Resumen del contenido incluido en la página 20
TRoUbLeSHooTING PRobLem cH K SoLUTIoN Burners burn with a yellow or orange flame, in Inspect Spider/Insect screens for possible obstructions . Clean Spider/Insect screens . R efer to “ANNUAL conjunction with the smell of gas. (Blockage of holes .) MAINTENANCE” . Symptoms: The excess flow safety device, which is part of the To reset the excess flow safety device close the LP barbecue to cylinder connection, may have activated . tank valve and turn all burner control knobs to the OFF Burners do
