Resumen del contenido incluido en la página 1
GAS GRILL
LP Gas Grill Owner’s Guide
Guía del propietario del asador de gas licuado de propano - Pg 23
Guide de l’utilisateur du grill à gaz PL - Pg 39
310/320
#89478
#00000
WARNING: Follow all leak-check
YOU MUST READ THIS OWNER’S GUIDE
procedures carefully in this manual prior
BEFORE OPERATING YOUR GAS GRILL.
to barbecue operation. Do this even if
the barbecue was dealer-assembled.
DANGER
If you smell gas:
NOTICE TO INSTALLER: These instructions
1. Shut off gas to the appliance.
mus
Resumen del contenido incluido en la página 2
WARNINGS DANGERS AND WARNINGS DANGER Failure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manual may result in serious bodily injury or death, or in a fire or an explosion causing damage to property. WARNINGS Do not store a spare or disconnected liquid propane cylinder under or near this barbecue. Improper assembly may be dangerous. Please follow the assembly instructions carefully. ® After a period of storage, and/or nonuse, the Weber gas barbecue should be
Resumen del contenido incluido en la página 3
WARRANTY, GARANTÍA, GARANTIE ® Weber-Stephen Products Co. (Weber) hereby warrants to the ORIGINAL PURCHASER of this Weber This Limited Warranty does not cover any failures or operating difficulties due to accident, abuse, WARRANTY WARRANTY gas grill that it will be free of defects in material and workmanship from the date of purchase as follows: misuse, alteration, misapplication, vandalism, improper installation or improper maintenance or 3 service, or failure to perform normal and routine
Resumen del contenido incluido en la página 4
EXPLODED VIEW 310 VISION ÉCLATÉE, DIAGRAMA DE DESPIECE Genesis_310_LP_US_09 4
Resumen del contenido incluido en la página 5
EXPLODED VIEW LIST 310 LISTA DEL DIAGRAMA DE DESPIECE, LISTE DE LA VISION ÉCLATÉE 5 1. Shroud Hardware 18. Catch Pan 35. Back Panel Accesorios de la cubierta Plato recolector Panel trasero Structure de protection Egouttoir Panneau arrière 2. Thermometer 19. Front Panel 36. Tank Scale Termómetro Panel frontal Báscula del tanque Thermomètre Panneau avant Plateau de la bouteille 3. Thermometer Bezel 20. Left Door 37. Manifold Moldura decorativa del termómetro Puerta izquierda Múltiple Plaque
Resumen del contenido incluido en la página 6
EXPLODED VIEW 320 VISION ÉCLATÉE, DIAGRAMA DE DESPIECE Genesis_320_LP_US_2010 6
Resumen del contenido incluido en la página 7
EXPLODED VIEW LIST 320 LISTA DEL DIAGRAMA DE DESPIECE, LISTE DE LA VISION ÉCLATÉE 7 1. Shroud Hardware 18. Catch Pan Holder 35. Front Burner Tube Accesorios de la cubierta Soporte del plato recolector Tubo quemador frontal Structure de protection Support d’égouttoir Tube du brûleur avant 2. Thermometer 19. Disposable Drip Pan 36. Igniter Electrode Termómetro Bandeja de goteo desechable Electrodo del encendedor Thermomètre Egouttoir jetable Igniter Eectrode 3. Thermometer Bezel 20. Catch Pan
Resumen del contenido incluido en la página 8
GENERAL INSTRUCTIONS ® ® ® Your Weber gas barbecue is a portable outdoor cooking appliance. With the Weber WARNING: Your Weber gas barbecue shall not be used GENERAL INSTRUCTIONS gas barbecue you can grill, barbecue, roast and bake with results that are difficult to under overhead combustible construction. ® duplicate with indoor kitchen appliances. The closed lid and Flavorizer Bars produce ® WARNING: Your Weber gas barbecue is not intended to be that “outdoor” flavor in the food. ® Th
Resumen del contenido incluido en la página 9
GENERAL INSTRUCTIONS Slide out Bottom tray - Remove excess grease, then wash with warm soapy water, Preserve Your Stainless Steel - Your grill or its cabinet, lid, control panel and shelves then rinse. may be made from stainless steel. To keep the stainless steel looking its best is a 9 simple matter. Clean it with soap and water, rinse with clear water and wipe dry. For ® Flavorizer bars and Cooking grates - Clean with a suitable stainless steel bristle stubborn particles, the use of a non-
Resumen del contenido incluido en la página 10
a GAS INSTRUCTIONS To connect the hose to the cylinder: GAS INSTRUCTIONS A) Pass the regulator hose through the side panel opening to the inside of the base cabinet. B) Locate hose retention clip (1) on regulator hose. Secure into slot (2) on underside of tank scale. WARNING: The hose must be secured to the tank scale with the Hose Retention Clip. Failure to do so could cause 1 2 damage to the hose resulting in a fire or explosion which can cause serious bodily injury or death, and damage
Resumen del contenido incluido en la página 11
GAS INSTRUCTIONS REMOVE CONTROL KNOBS & CONTROL PANEL FOR LEAK GAS INSTRUCTIONS 1 2 TESTING 11 You will need: Phillips screwdriver. A) Remove control knobs (1). B) Remove screw and washer from back of control panel with a Phillips screwdriver (2). C) Tilt the back edge of the control panel up. Push in on the front edge to release locking tabs. Carefully pull control panel away from frame (3). D) Disconnect the igniter wires from the ignition module (4). E) Replace control panel when Leak Ch
Resumen del contenido incluido en la página 12
GAS INSTRUCTIONS Check: GAS INSTRUCTIONS A) Hose to manifold connection (1). 320 B) Side burner hose to manifold connection and side burner hose to side burner gas line connection (2). * The grill illustrated may have C) Side burner hose to side burner connection, side burner valve and orifice slight differences than the connections (3). model purchased. WARNING: If there is a leak at connection (1, 2, or 3), 2 retighten the fitting with a wrench and recheck for leaks with soap and wat
Resumen del contenido incluido en la página 13
GAS INSTRUCTIONS SAFE HANDLING TIPS FOR LIQUID PROPANE GAS WARNING: Replacement LP tanks must match the ® CYLINDERS regulator connection supplied with this Weber gas 13 appliance. • Liquid Propane (LP) gas is a petroleum product as are gasoline and natural gas. LP gas is a gas at regular temperatures and pressures. Under moderate pressure, LIQUID PROPANE CYLINDER REQUIREMENTS inside a cylinder, LP gas is a liquid. As the pressure is released, the liquid readily vaporizes and becomes gas
Resumen del contenido incluido en la página 14
O D A G A P A OPERATING INSTRUCTIONS MAIN BURNER LIGHTING A) Open the lid (1). 2 B) Make sure all burner control knobs are turned OFF (2). (Push control knob down and turn clockwise to ensure that it is in the OFF position.) 5 WARNING: The burner control knobs must be in the OFF position before turning on the liquid propane cylinder tank 4 valve. If they are not in the OFF position, when you turn on the LP cylinder valve, the “excess gas flow control” feature will activate, limiting the
Resumen del contenido incluido en la página 15
O D A G A P A OPERATING INSTRUCTIONS DANGER 15 2 When the “excess gas flow control” feature is activated, a small amount of gas is still flowing to the burners. After turning OFF the cylinder and burner control knobs, wait at least 5 minutes for the gas to clear before attempting to light 1 the barbecue. Failure to do so may result in an explosive 5 flame-up, which can cause serious bodily injury or death. C) Turn the cylinder on by turning the cylinder valve counterclockwise (3). D) Ins
Resumen del contenido incluido en la página 16
OPERATING INSTRUCTIONS C) Turn the gas supply valve on (3). D) Push down and turn the side burner control valve to “HI” (4). E) Press the igniter button several times so it clicks each time (5). 320 CAUTION: Side burner flame may be difficult to see on a bright sunny day. WARNING: If the side burner does not light in five (5) seconds: a) Turn off the side burner control valve, main burners and gas supply at source. b) Wait 5 minutes to let the gas clear before you try 1 2 again, or try
Resumen del contenido incluido en la página 17
TROUBLESHOOTING PROBLEM CHECK CURE Burners burn with a yellow or orange flame, in Inspect Spider/Insect Screens for possible obstructions. Clean Spider/Insect Screens. (See Section “Annual conjunction with the smell of gas. (Blockage of holes.) Maintenance”) Symptoms: The excess flow safety device, which is part of the To reset the excess flow safety device turn all burner control Burners do not light. -or- Burners have a small barbecue to cylinder connection, may have activated. knobs and the
Resumen del contenido incluido en la página 18
SIDE BURNER MAINTENANCE SIDE BURNER MAINTENANCE 3 WARNING: All gas controls and supply valves should be in the “OFF” position. Make sure black wire is connected between the igniter and electrode. Make sure white wire is connected between the igniter and grounding clip. Spark should be a white/blue color, not yellow. 2 A) Igniter Wire (1) 1 B) Ground wire (2) C) Burner (3) Side Burner Grate Side Burner cap 1 Side Burner Ring & Head 2 Igniter Electrode Control Knob Igniter MAINTENANCE ® WEBER
Resumen del contenido incluido en la página 19
MAINTENANCE ANNUAL MAINTENANCE 19 INSPECTION AND CLEANING OF THE SPIDER/INSECT SCREENS To inspect the Spider/Insect screens, remove the control panel. If there is dust or dirt on the screens, remove the burners for cleaning the screens. Brush the Spider/Insect screens lightly with a soft bristle brush (i.e. an old toothbrush). CAUTION: Do not clean the Spider/Insect screens with hard or sharp tools. Do not dislodge the Spider/Insect screens or enlarge the screen openings. Lightly tap the
Resumen del contenido incluido en la página 20
MAINTENANCE D) Remove the two threaded 7/16” hex screws (a) that hold the manifold support a bracket to the cooking box. Pull the manifold and valve assembly towards you, at the same time lift the manifold assembly up to release the manifold brackets from the frame assembly. (b). b E) Slide the burner assembly out from under the guide screw and washer (1) in the corners of the cooking box. 1 F) Lift and twist the burner assembly slightly, to separate the crossover tube (2) from the burners.
