Resumen del contenido incluido en la página 1
GE Monogram ®
Installation
Instructions
Stainless Steel
Professional Outdoor
Cooking Centers
48" Natural g'a,s mode£:
ZGG48N42
ZGG48N3 I
ZGG48N40
ZGG48N30
48" Liquid Ih'@a)_e model, s:
ZGG48L42
ZGG48L31
ZGG48L40
ZGG48I_30
36" Natural g'a,s modd, w
ZGG36N31
ZGG36N21
ZGG36N30
ZGG36N20
36" Liquid !'r@a_e modd, w
ZGG36L31
ZGG36L21
ZGG36L30
ZGG36120
27" Natural g'a,s modd, s:
, ,c _ c
ZG(,21N21
Z(,(,2 IN20
27 _'Liquid Propa_e model, s:
, ,c _ c
Z(,G21121
, ,c_ c
ZG(,2 zL20
Resumen del contenido incluido en la página 2
Before wm begin--Read these instructions completely and careflllly. IMPORTANT: Sine these instructions for local inspector's use. IMPORTANT: OBSERVE ALL GOVERNING CODES AND ORDINANCES. NOTE TO INSTALLER: Be sure to leave these instructions with tile Constm_er. NOTE TO CONSUMER: Keep these instructions _dth your Use and Care Book for ftlture reference. If vou hme questions concerning tile Installation of this cooking center requires installation of this product, call tile GE basic mechanical skil
Resumen del contenido incluido en la página 3
Design Infi)rmation Ouldoor Cooki_g Ce_te*w Monogram Outdoor Cooking Centers are ModeLs tactorv set for LP or natural gas. Order the Available model t0r your installation situation. 48" Liquid Propane models: 48" Natural gas models: ZGG48N42 ZGG48L42 4 grill bm'ners, 2 rear infl'a red bm'ners 4 grill burners, 2 rear infl'a red bm'ners ZGG48N31 ZGG48L31 3 grill bm'ners, 1 rear infl'a red bm'ner, and 3 grill burrJers, 1 rear infl'a red buriler, and 2 side bm'ners 2 side bm'ners ZGG48N40 ZGG48IA0 4
Resumen del contenido incluido en la página 4
Design Inf_)rmation Min.to Combustibles Product 3"Clearancefor Lid Dimensions / 13-7/8" & Clea__ances 16-1/4' 24-3 2" 27" Wide Models mbustibles 3" Clearance for Lid 36" Wide Models Min. to Combustibles 47-7/8" 48" Wide Models
Resumen del contenido incluido en la página 5
Design Infbrmation Outdoor ( ooki_g C¢_ter,s 36" and 48" Models: • Mon(_gram Outdoor Cooking Centers are Advance • In a non-combustible (masonry) enclosure, designed to be installed on a grill cart or into Planning an enclostlre. the grill drops into the opening and hangs 27" Models: fl'om its side flanges. A deck is not required • In a non-combustible (masonry) enclosure, for support. the grill drops into the opening. A deck (1i" • Insulated jackets are available to allow these ledge on each si
Resumen del contenido incluido en la página 6
Installation Ouldoor Cooki_g" ( e_ler,s • Open the box and remove packaging. Step • Open the grill lid and remove white plastic tie-downs on b/irners. • Remove side burner grate and aeration pan. • Remove tie-downs on b/lrners. Remove the • Open the hardware accessoix carton and P<_ckagi'ng check contents. Coupler and Nipple Natural Gas Regulator (Natural GasModels) LP Regulator Type 1 Acme, 2B lb. LPtank 1/2"NPTto 3/8 flare adaptor (LPmodels only) <'///!! ! ! ! ! ! ! ! ! _ '_\\\.',.',.\'_ Warmi
Resumen del contenido incluido en la página 7
Installation Outdoor Cooki_g Center,_ All Outdoor Cooking Centers can be installed (:AUTION: The grill is heavy. 2 people are on a cart designed specifically for that model required to lift and place tile grill into tile size. Follow the installation instructions cart or tile enclosure. provided with the carts to install. Proceed to Provide (;as supply to complete the installation. Support • All models may be installed into a grill when exhaust is directed to a window or Built4n combustible or n
Resumen del contenido incluido en la página 8
Installation Outdoor Cooki_g Ce_tler,s InstallElectrical InstallElectrical 36" Modeh tisserie Outletfor Rotisserie OnRightside OnRightside 12"Min. to Combustibles (6.5AMPMin. 12" Min.to Combustibles (6.5AMPMin.) 3" Clearancefor Lid 3" Clearance for Lid _23-3/4" 34-1 40-1 35-1/2" penmg for 6asSupply for GasSupply Line Line "Openingfor AccessDoors Opening for 9-1/8" AccessDoors 10-1/8" 36" wide models: 36" wide models: Installation in a non-combustible enclosure. Installation in a combustible encl
Resumen del contenido incluido en la página 9
Installation Outdoor ( oohb_g Ce_ters PRODUCT ST() [_4(;E When storing LP models indoors, discon- nect the LP tank. Store the tank outdoors in a well ventilated area. Provide Do not store spare LP tanks in or near tile Gas & Otltdoor Cooking Center enclosure. E#ctrical Resistantto L.P.Gas LP GAS MODELS _ hreadingCompound Must Be Coupler Sleeve Suppl>, • Com_ect tile regulator/Quick Cmmect Inlet ve assembly to the hose attached to the grill. • Tile Quick Cmmect type coupling requires the user to
Resumen del contenido incluido en la página 10
Installation Outdoor Cooki_g (enters ELECTRICAL SUPPLY DO NOT UNDER ANY CIRCUMSTAN(:ES, CUT OR REMOVE THE THIRD (GROUND) Models with rotisserie require 120V, 60Hz. PRONG FROM THE POWER CORD. and cmmected to an individual properly grounded branch circuit protected by a 15 • For 27" wide built-in grills, locate the amp circuit breaker or time delay filse. electrical outlet on the left hand side within The power cord on the rotisserie is equipped with a three-prong (grotmding) plug which reach of t
Resumen del contenido incluido en la página 11
Installation Ouldoor Cooki_g" ( e_Her,s :2 IN 5 Check Burner, s, iii ii i i'i _ i I Drip 7 ays iii i i !_ and G' ates ,il i I i i ! i'i / iil • During shipping parts, such as burners and • Remove tile smoker tray (if so equipped). Check to be sm'e smoker bm'ner and reflectors may haxe mined. Check to be sure all parts are in position. deflector plate are installed properly, The bm'ner and plate should be placed over the holding pin at tile back and fl'ont of tile grill. CORRECT BurnerRests Level
Resumen del contenido incluido en la página 12
Installation Outdoor Cooking (enters • A match stick extension rod is provided on SOllle Illodels. Do not attempt to light tile grill if tile odor of gas is present. TO MATCH LIGHT: • Insert a match stick DO NOT LIGHT) securely into tile clip end of tile match stick CAUTION: Keep hands and thce as t_u"away Lighting extension rod, from tile grill as possible when lighting. the Grill • Light tile match stick held on tile end of tile rod and hold against a burner port towards • Open tile lid and re
Resumen del contenido incluido en la página 13
Installation Outdoor Coohb_g (enters A_!jusm_ents should not be required, unless vibration during transit or variations in local Ste 7 gas supply make minor a_!justments necessary. Ac!justments must be made by a qualified Adjusting technician at tile time of installation. Extreme the Burners care should be used if ac!justments are made after installation. • Turn gas supply on. \ \ \ • Push and turn tile burner control knobs to tile "LITE" position. Up to 20 seconds may be required to to purge ai
Resumen del contenido incluido en la página 14
Installation Ouldoor CookD_g Ce_ter,s 27" Wide Models: 36" and 48" Wide Models: hzstaU • Slide the motor down into the channel on • The motor will rest on the cast iron block Rotis_serie the lett side and tighten thumb screw. and can be tightened against the grill by turning the black knob. • To use, place pointed end of the skewer into ((/so _,q_i/,i,,,cl) the motor, mad the threaded end resting on • To use, place pointed end of the skewer into the right side support. the motor, and the threade
Resumen del contenido incluido en la página 15
Install Access Doors Outdoor Cooki_tg" ( e_tler,s hi, stall \\ Optional \ Access Doors ZXAI) CSS or ZXSI)CSS • The opening fiw double and single access doors should be 24-1/8" wide and 18-1/4" high. • Place the fl'ame into the opening and secure with screws on all sides. • Hang the doors on the hinges as shown. 1.5
Resumen del contenido incluido en la página 16
Note: While performing installations described in this book, safety glasses or goggles should be worn. 7;_obtain _peciflc i_ffinmalion com:erni_g ahr Monogwzm pwducl or service5 _zdl (_E Answer C_ozter _; consu*mn i_lfinm(zHo_l se*wi : al 800. 626.2000_a_ 0 time, d( 0 m nigfiL F_n Mon_g*gzm k)_aI s_.*_6.,i_ your ar*,a, _all 1-800-444-184 5. Pub. No. 49-80009 NOTE: Iho(h_ct impl ox emem is a c(mmmmg elide ivoi al Gellelal Dwg. No. 164D3333P227 I_lecllic _'l_ele_le, malerials, appearaJ_ce and spec
