Bedienungsanleitung Cres Cor CO151FUA12

Inhaltszusammenfassung zur Seite Nr. 1

Ovens
FL-2202-MP-M
Rev. 1 (4/08)
Page 1 of 10
5925 Heisley Road • Mentor, OH 44060-1833
INSTALLATION, OPERATION and MAINTENANCE
MANUAL for Cres Cor
CONVECTION and RETHERM OVENS
with Microprocessor Control and Food Probe
CO151FUA12 CO151HUA6
CO151F1818 CO151H189
RO151FUA18 RO151HUA9
Call Toll-free: 877-CRES COR (273-7267) • Fax: 800-822-0393 • www.crescor.com

Inhaltszusammenfassung zur Seite Nr. 2

Ovens FL-2202-MP-M Rev. 1 (4/08) Page 2 of 10 5925 Heisley Road • Mentor, OH 44060-1833 TABLE OF CONTENTS SUBJECT PAGE INSTALLATION INSTRUCTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3 OPERATING INSTRUCTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4, 5 MAINTENANCE INSTRUCTIONS How to Clean the Unit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Inhaltszusammenfassung zur Seite Nr. 3

Ovens FL-2202-MP-M Rev. 1 (4/08) Page 3 of 10 5925 Heisley Road • Mentor, OH 44060-1833 INSTALLATION INSTRUCTIONS VENTING YOUR OVEN: 3. Most jurisdictions consider our low-temperature ovens 1. The purpose of ventilating hoods is to direct and (maximum temperature is 350°F/177°C) as low-heat capture smoke, grease-laden vapors, heat, odors, or appliances not requiring vent hoods. fumes. 4. Installation must conform with local codes. The 2. Low temperature equipment (maximum temperature auth

Inhaltszusammenfassung zur Seite Nr. 4

Ovens FL-2202-MP-M Rev. 1 (4/08) Page 4 of 10 5925 Heisley Road • Mentor, OH 44060-1833 OPERATING INSTRUCTIONS POWER SWITCH PRODUCT KEYS CONTROL MODE SETPOINTS ON TIME - TEMPERATURE RETHERM COOK PROBE TIMED TIME SET HEAT COOK HOLD SELECT PROBE OVEN START STOP TEMP HOLD OFF POWER Figure 1: Control Panel (For parts description, refer to page 8.) HOW TO START UNIT: 3. Press the SET button to enter the temperature into the control. (for fi rst-time operation only) A new oven needs to “burn off” fact

Inhaltszusammenfassung zur Seite Nr. 5

Ovens FL-2202-MP-M Rev. 1 (4/08) Page 5 of 10 5925 Heisley Road • Mentor, OH 44060-1833 OPERATING INSTRUCTIONS, continued: To manually end the Cook/Retherm, Probe, or Hold mode: NOTE: Do NOT change the mode of the controls (probe or timed) while oven is operating in a Cook/Re- Press the STOP button during any of the above modes and therm cycle. Oven must be off, or in the HOLD cycle, the control will end that mode. If in the Cook/Retherm or to change the timer or probe operation. Probe mode

Inhaltszusammenfassung zur Seite Nr. 6

Ovens FL-2202-MP-M Rev. 1 (4/08) Page 6 of 10 5925 Heisley Road • Mentor, OH 44060-1833 MAINTENANCE INSTRUCTIONS HOW TO CLEAN THE UNIT Cleaning Hints: CAUTION 1. Use the mildest cleaning procedure that will do the job. 1. ALLOW CABINET TO COOL. 2. Always rub in the direction of the polish lines to avoid 2. REMOVE HOT UNIT BEFORE scratching the surface. CLEANING. 3. Use only a soft cloth, sponge, fi brous brushes, plastic or stainless steel pad for cleaning and scouring. Wipe up spills as

Inhaltszusammenfassung zur Seite Nr. 7

Ovens FL-2202-MP-M Rev. 1 (4/08) Page 7 of 10 5925 Heisley Road • Mentor, OH 44060-1833 MAINTENANCE INSTRUCTIONS TROUBLE-SHOOTING GUIDE, continued PROBLEM POSSIBLE CAUSE SOLUTION 1. Fuse 1. Replace 2. Control 2. Replace Cabinet does not heat, or doesn’t heat 3. Sensor 3. Replace properly 4. Heater contactor 4. Replace 5. Loose wiring at heater contactor 5. Replace 6. On/Off Switch 6. Replace 1. On/Off Switch 1. Replace 2. Fuse 2. Replace Blowers do not operate 3. Blower 3. Replace 4. Control 4.

Inhaltszusammenfassung zur Seite Nr. 8

Ovens FL-2202-MP-M Rev. 1 (4/08) Page 8 of 10 5925 Heisley Road • Mentor, OH 44060-1833 REPLACEMENT PARTS, continued Include all information on nameplate when ordering parts 1 2a 2a 2 MODE SETPOINTS ON TIME - TEMPERATURE RETHERM COOK PROBE TIMED TIME SET HEAT COOK HOLD SELECT PROBE OVEN START STOP HOLD TEMP OFF POWER FIGURE 2: CONTROL PANEL Hot Unit Replacement Parts ITEM DESCRIPTION Part No. ITEM DESCRIPTION Part No. PARTS for 6200W, 3-PH UNITS 1. Switch (On/Off) 0808-113-01-K 15. Terminal B

Inhaltszusammenfassung zur Seite Nr. 9

Ovens FL-2202-MP-M Rev. 1 (4/08) Page 9 of 10 5925 Heisley Road • Mentor, OH 44060-1833 REPLACEMENT PARTS, continued Include all information on nameplate when ordering parts 9 15 10 7 8 19 L3 T3 L2 T2 L1 T1 16 18 6 5 3 4 FIGURE 3; Hot Unit w/o Top Cover (For parts description, refer to page 8) 17 6 13 12 14 FIGURE 4; Bottom of Hot Unit, Cover Removed (For parts description, refer to page 8) Call Toll-free: 877-CRES COR (273-7267) • Fax: 800-822-0393 • www.crescor.com

Inhaltszusammenfassung zur Seite Nr. 10

POWER INPUT HEATERS HIGH TEMP. HIGH TEMP. LIMIT, LEFT LEFT RIGHT LIMIT, RIGHT L2 L1 G 67 68 TERMINAL BLOCK 4 8 REAR REAR 21 3 TERMINAL 15 14 13 12 BLOCK FRONT FRONT VENT FAN VENT FAN 11 LEFT RIGHT 9 18 M 6 M HEATER CONTACTOR 19 5 11 2 22 16 22 8 20 3A 3A 4 FUSES FUSES 1 3A 3A 9 23 17 23 24 24 27 8200W, SINGLE PHASE 29 6 WIRE KIT 5812-907 FAN TIMER BLOWER MOTORS TERMINAL 12 3 BLOCK POWER INPUT BM BM BM HEATERS HIGH TEMP. 10 5 76 RIGHT L2 L1 G 25 LM R LIMIT, RIGHT 31 68 TERMINAL BLOCK 5 4 REAR 21