Inhaltszusammenfassung zur Seite Nr. 1
NATURAL GAS
DECORATIVE PATIO FIRE
OWNER’S OPERATION AND INSTALLATION MANUAL
®
Models
PC4670NG and
PC3460NG
WARNING: Improper installa-
WARNING: If the information in this manual is not
tion, adjustment, alteration,
followed exactly, a fire or explosion may result
service, or maintenance can
causing property damage, personal injury, or
cause injury or property dam-
loss of life.
age. Read the installation,
— Do not store or use gasoline or other flammable
operating and maintenance,
vapors and liq
Inhaltszusammenfassung zur Seite Nr. 2
NATURAL GAS DECORATIVE PATIO FIRE 1. This appliance is only for use with the SAFETY WARNING: Any change to this type of gas indicated on the rating plate. appliance or its controls can be INFORMATION 2. The installation must conform with lo- dangerous. cal codes or, in the absence of local codes, with the National Fuel Gas WARNINGS WARNING ICON G 001 WARNING: Do not use in- Code, ANS Z223.1, NFPA 58. doors. It is for outdoor use only. IMPORTANT: Read this owner’s 3. If you smell gas This appl
Inhaltszusammenfassung zur Seite Nr. 3
OWNER’S MANUAL 23. Do not allow water to contact the lava 28. Turn appliance off and let cool before SAFETY rock or logs. Water from rain, sprin- servicing or repairing. INFORMATION klers, toys, horseplay, etc. can damage 29. Use only original replacement parts. lava rock and logs. When heated, they This appliance must use design-specific (Continued) may crack, break, or even explode. This parts. Do not substitute or use generic could cause severe injury. parts. Improper replacement parts could
Inhaltszusammenfassung zur Seite Nr. 4
NATURAL GAS DECORATIVE PATIO FIRE UNPACKING INSTALLATION DECORATIVE GAS PATIO FIRE SPECIFICATIONS NATURAL GAS: WARNING: Do not remove WARNING: Only a qualified RATED PRESSURE* 7.0" W.C. the metal data plates attached service person must install gas to this appliance. The data plates piping and connect appliance to MINIMUM GAS contain important warnings and gas supply. Follow all local codes. PRESSURE* 5.0" W.C instructions. MAXIMUM GAS PRESSURE* 10.5" W.C. 1. Remove lava rock and log pack from
Inhaltszusammenfassung zur Seite Nr. 5
OWNER’S MANUAL CHECKING GAS INSTALLATION CAUTION: Use pipe joint seal- CONNECTIONS (Continued) ant that is resistant to liquid pe- troleum (LP) gas. WARNING: Test all gas pip- CONNECTING TO GAS We recommend that you install a sediment ing and connections for leaks SUPPLY trap in supply line as shown in Figure 3. after installing or servicing. Cor- Installation Items Needed Locate sediment trap where it is within rect all leaks at once. reach for cleaning. Install in piping system Before instal
Inhaltszusammenfassung zur Seite Nr. 6
NATURAL GAS DECORATIVE PATIO FIRE SETUP BATTERY INSTALLATION INSTALLATION Continued Your Comfort Glow Patio Fire is designed Your Comfort Glow Patio Fire uses an elec- to operate with lava rock piled in and around tronic ignitor which requires one AA alka- Test Pressures Equal To or Less Than the burner, and refractory logs placed on top line battery (not included). The battery com- 1/2 PSIG (3.5 kPa) of the lava rock. partment is located in the ignitor module 1. The appliance must be isolated f
Inhaltszusammenfassung zur Seite Nr. 7
OWNER’S MANUAL 8. To shut off appliance, push shutoff LIGHTING OPERATING switch to the OFF position. INSTRUCTIONS APPLIANCE WARNING: Close equipment Lighting Using the Electronic FOR YOUR SAFETY shutoff valve when appliance is Spark Ignition System not in use. READ BEFORE 1. Open equipment shutoff valve. LIGHTING 2. If you smell gas, STOP! Turn the Lighting Manually with a Match equipment shutoff valve to OFF. Check 1. Open equipment shutoff valve. gas connections for leaks. Do not con- WARNIN
Inhaltszusammenfassung zur Seite Nr. 8
NATURAL GAS DECORATIVE PATIO FIRE TROUBLESHOOTING WARNING: Turn off appliance Note: For additional help, visit DESA and let cool before servicing. Only International’s technical service web site a qualified service person should at www.desatech.com. service and repair appliance. Note: All troubleshooting items are listed in order of operation. OBSERVED PROBLEM POSSIBLE CAUSE REMEDY When ignitor button is pressed, there is no 1. Ignitor electrode not connected to igni- 1. Reconnect ignitor cable
Inhaltszusammenfassung zur Seite Nr. 9
OWNER’S MANUAL TROUBLESHOOTING Continued OBSERVED PROBLEM POSSIBLE CAUSE REMEDY Delayed ignition of burner 1. Manifold pressure is too low 1. Contact local natural gas company 2. Burner orifice or burner manifold ports 2. Clean burner (see Cleaning and Mainte- clogged nance, page 10) or replace burner orifice Burner backfiring during combustion 1. Burner orifice or burner manifold ports 1. Clean burner (see Cleaning and Mainte- clogged or damaged nance, page 10) or replace burner orifice 2. Dama
Inhaltszusammenfassung zur Seite Nr. 10
NATURAL GAS DECORATIVE PATIO FIRE CLEANING AND REPLACEMENT ACCESSORY MAINTENANCE PARTS Purchase these fireplace accessories from your local dealer. If they can not supply Regularly check all burner ports for block- Note: Use only original replacement parts. these accessories, call DESA International’s age. Burner ports are the small holes on top This will protect your warranty coverage for Sales Department at 1-800-432-2382 for of the burner. Also check the ignitor port for parts replaced under
Inhaltszusammenfassung zur Seite Nr. 11
OWNER’S MANUAL These Parts Centrals are privately-owned businesses. They have agreed to support our PARTS CENTRALS customer’s needs by providing original replacement parts and accessories. Baltimore Electric Dayton Hardware Washer Equipment Co. 1348 Dixwell Avenue P.O. Box 275 1715 Main Street Hamden, CT 06514-0322 North Dayton Station Kansas City, MO 64108-2195 1-800-397-7553 Dayton, OH 45404-0275 KS, MO, AR 203-248-7553 All States 816-842-3911 Parts Department 937-258-3721 www.washerparts.com
Inhaltszusammenfassung zur Seite Nr. 12
NATURAL GAS DECORATIVE PATIO FIRE 20 ILLUSTRATED PARTS 1 BREAKDOWN PATIO FIRE PC4670NG 18 20 PC3460NG 4 2 12 (Note: Appearance of firepit may vary 13 depending on model.) 19 11 3 14 25 22 10 5 24 6 21 17 15 8 9 16 26 7 23 107214 For more information, visit www.desatech.com 12
Inhaltszusammenfassung zur Seite Nr. 13
OWNER’S MANUAL This list contains replaceable parts used in your appliance. When ordering parts, follow the instructions listed PARTS LIST under Replacement Parts on page 10 of this manual. PATIO FIRE PC4670NG KEY PART NO. PART NO. PC3460NG NO. FOR PC4679NG FOR PC3460NG DESCRIPTION QTY. 1 106116-01 106116-01 Burner Assembly 1 2 106117-01 106117-01 Burner Plate 1 3 106118-01 106118-01 Burner Plate Bracket 4 4 106119-01 106119-01 Injector, NG 1 5 106725-02 106725-02 Outlet Tube Assembly 1 6 106208
Inhaltszusammenfassung zur Seite Nr. 14
WARRANTY INFORMATION KEEP THIS WARRANTY Model Serial No. Date Purchased Always specify model and serial numbers when communicating with the factory. We reserve the right to amend these specifications at any time without notice. The only warranty applicable is our standard written warranty. We make no other warranty, expressed or implied. LIMITED WARRANTY COMFORT GLOW VENTED GAS PATIO FIRE DESA International warrants this product to be free from defects on the firepit for five (5) years and all o
