Inhaltszusammenfassung zur Seite Nr. 1
__
-
i
1
Rev D
QRllCO
.~ .
This manual contains IMPORTANT
t. ,,
,.
WARNINGS and lMSTAUCTlQNS
READ AND RETAIN FOR REFERENCE
P/N 800-064 SERIES A
1500 psi(103 bar) OPERATING PRESSURE
1800 psi (124 bar) MAXIMUM WORKING PRESSURE
Inhaltszusammenfassung zur Seite Nr. 2
bR]$ECTIoN HAZARD ~~~~~~~~~~~~~~~~~~~~~~~~~ IF 1 W E ,~~~~,~~~~~~~"~~~~~,~~~*~~~~~~~'~~~~~~~~~~Fi Fluids under high pressure from spray or leaks can Do not spray flammable liquids. Do not operate the penetrate the skin and cause extremely serious engine where combustible fumes or dust may be injury, including the need for amputation. present. GAS ~WE~A~KSO~$~~~~~~~~~~~~ NEVER point the spray gun at anyone or any part of the body. NEVER fill fuel tank whi
Inhaltszusammenfassung zur Seite Nr. 3
.. ENGINE KILL LEVER 7 P, LSPRAY HOSE \ Refer to the engine instruction booklet provided with Connect To Water Supply the unit. CAUTION Before attaching to water supply. check local plumbing code regarding cross-connection to Install Hose and Spray Gun Connect the spray hose to the spray gun by inserting water supply. the pin at the end of the hose into the quick Do not exceed 1 60°F (70%) water temperature to disconnect coupler on the gun. Connec
Inhaltszusammenfassung zur Seite Nr. 4
When shutting down for the day or weekend, shut off Startup unit, shut off water supply valve, and trigger gun to Before startino. be sure to read the safety warninas and ~~ - -. release pressure. Wipe off the unit with a damp rag. setup instructions. Check the oil and gasoline levels daily. CAUTION Shut off cleaning unit when not actually spraying. for longer pump life. The pump will overheat if left Turn on the water supply running for over 10 minutes
Inhaltszusammenfassung zur Seite Nr. 5
.i 'ROBLEM CAUSE SOLUTION ingine Will Not Start No gasoline in fuel tank or Fill the tank with gasoline, open fuel shut-off )r Hard To Start. carburetor. valve. Check fuel line and carburetor. Water in gasoline or old fuel. Drain fuel tank and carburetor. Use new fuel and dry spark plug. Choked improperly. Flooded Open choke and crank engine several times to engine. clear out the gas. Dirty carburetor air filter. Remove and clean. Spark plug dirty
Inhaltszusammenfassung zur Seite Nr. 6
. .. .. 6 801-641 . . .. .. .,,".. _. . ..,, ~~. . . . ., . . . . . .. ~ .~. ~. .. ..
Inhaltszusammenfassung zur Seite Nr. 7
I Pressure Washer Assembly, 800-064 ~ ! REF. PART REF. PART NO. No. DESCRIPTION CITY. NO. NO. DESCRIPTION QTY. 1 800-130 GUN ASSEMBLY, see parts 33 '801-090 OUICK COUPLE. male 5 10 1 34 '801 -552 TIP. 2506 MEGI 1/4 thd.. 2Fo 1 drawing/list page 2 '801-665 TIP. 0006 MEG, 1/4 thd.. Oo 1 35 801-723 LABEL. Model 1535 1 5 '801.666 TIP, 1506 MEG, 1/4 thd.. 15O 1 36 800-080 CHASSIS WELDMENT 1 4 800-081 PUMP ASSEMBLY. see Darts 37 801-529 BELTGUARD. base 1 drawing/list page
Inhaltszusammenfassung zur Seite Nr. 8
8. Lubricate each plunger and carefully slide manifold NOTE: Three sizes of metric wrenches are necessary for servicing the pump; M30, onto crankcase. M10 and M6 Allen wrench. 9. Replace the eight capscrews and snug them up. Valves: Torque to 16 ft. Ibs. (2.2 K/m). 1. Remove the hex plug (5)from manifold (6) using M30 NOTE: The eight capscrews must be torqued wrench. evenly to apply equal pressure on the manifold so that it seats properly and 2. Examine O-ring
Inhaltszusammenfassung zur Seite Nr. 9
i "PACKING 81 RETAINER ~15~16 KIT 801-664 Includes: TIl) L11'-12-14 PLUNGER REPAIR REF. 13 'I( KIT 801 -474 NO. QTY ., 1 Includes: 11 VALVE UNIT OIL SEAL KIT PACKING KIT REF. 12 1 KIT 801 -472 801 -658 801-662 NO. QTY 13 1 14 1 Includes: 17' 3 15 1 REF. REF. REF. 18 3 3 NO. QTY NO. QTY NO. QTY 19 *Three kits needed 3 6 16 3 12 6 20 3 for entire pump. REF. PART NO. NO. DESCRIPTION QTY NO. NO. DESCRIPTION QTY 1 801-651 SCREW. M8 x 60 MM 22 801-660 8 FLINGER
Inhaltszusammenfassung zur Seite Nr. 10
PART$ Gun Assembly, 800-130 REF. PART NO. NO. DESCRIPTION QTY 1 801-134 TUBE. 32" 1 2 801-674 GRIP 1 I"liri"W 3 801-009 COUPLER, female quick disconnect 1 SERVICE ..eA8,8!* 4 801-638 SPRAY GUN, lreDlaceable Gun, Cartridge Replacement pans include items 5-18) 1 5 801-639 CARTRIDGE 1 1. Press access pin (1 2) from gun handle and remove 6 801-671 HOUSING 1 access plate (14) by sliding plate backwards. 7 801-670 HEX PLUG 1 Remove cartridge (5) from housing (6) by u
Inhaltszusammenfassung zur Seite Nr. 11
ENGINE BRIGGS & STRATTON 4 cycle, single cylinder air cooled, 7 hp GASOLINE TANK 4 quarts (3.79 liter) capacity ! WATER PUMP: 1500 PSI (103 bar) mar. pressure; 3-1 /2 GPM (13.25 liter/min). WEITED PARTS: Stainless Steel. Aluminum. Phenolic Plastic. Ceramic Liners, Nitrile Rubber. UNIT WEIGHT: 156 Ib I71 kg1 40 (1016 mm) OVERALL DIMENSION: Length: Widlh: 28" (711 mm) Height: 24" (610 mm) MAX. WATER TEMPERATURE: 160° (70" CI INLET HOSE CONNECTION: 3/4 garden hose (I)
Inhaltszusammenfassung zur Seite Nr. 12
.. THE GRACO WARRANTY Gracolnc.warrantsallequipmentmanufacturedbyitandbear~ngitsnametobefreefromdefectsin material and workmanshlp under normal use and Seivtce. This warranty extends to the ortglnal purchaSerforaperiodaf12monthsframthedateofpurchaseandappliesonlywhentheequipment is installed and operated !n accordance with written factory recommendations This warrantydoes not cover damage or wear which. in the reasonable judgment of Graco, awes from misuse. abrasion. cor
