Bedienungsanleitung Traulsen & Co. IncRPP232L-FHS

Inhaltszusammenfassung zur Seite Nr. 1

Traulsen & Co., Inc.
Quality Refrigeration
OWNER’S MANUAL
Instructions for the installation
and maintenance of most Traulsen models as well as
instructions to operate the following special models:
Pizza Proofer Model
RPP232L-FHS
This Traulsen unit is built to our highest quality standards. We build our refrigerators, freezers and heated
cabinets this way as a matter of pride. This philosophy has made Traulsen the leader in commercial refrig-
eration since 1938. We thank you for your choice an

Inhaltszusammenfassung zur Seite Nr. 2

TABLE OF CONTENTS I. THE SERIAL TAG Page 1 II. RECEIPT INSPECTION Page 2 III. INSTALLATION a-Location Page 2 b-Packaging Page 2 c-Roll-In Model Installation Page 2 d-Wiring Diagram Page 2 e-Power Supply Page e f-Clearance Page 3 IV. CARE & MAINTENANCE a-Cleaning The Exterior Page 3 b-Cleaning The Interior Page 3 c-Hinge Replacement Page 3 d-Replacing The Gaskets Page 3 V. OTHER a-Service Information Page 3 b-Spare Parts Page 4 c-Warranty Registration Page 4 d-Interior Arrangements Page 4 VI. PIZ

Inhaltszusammenfassung zur Seite Nr. 3

II. RECEIPT INSPECTION III. INSTALLATION (continued) All Traulsen products are factory tested for perfor- III. c - ROLL-IN MODEL INSTALLATION: mance and are free from defects when shipped. The Roll-In cabinets set on the floor require the floor area utmost care has been taken in crating this product to to be flat and level. In addition, after the cabinet is set protect against damage in transit. All interior fittings in place, sealant should be used around the perimeter have been carefully s

Inhaltszusammenfassung zur Seite Nr. 4

III. INSTALLATION (continued) IV. CARE & MAINTENANCE (cont’d) III. f - CLEARANCE: IV. d - REPLACING THE GASKETS: In order to assure optimum performance, your To remove the gasket to be replaced, grasp it firmly Traulsen unit MUST have an adequate supply of air to by one corner and pull it out. Before attempting to function properly. Therefore, the operating location install a new gasket, both the unit and the gasket it- must either have a minimum of 12” clearance over- self must be at room tem

Inhaltszusammenfassung zur Seite Nr. 5

V. OTHER (cont’d) V. b - SPARE PARTS: V. d - INTERIOR ARRANGEMENTS: Spare or replacement parts may be obtained through Traulsen proofer and proofer retarder models are de- a parts supplier or one of our authorized service signed to accommodate roll-in bakery racks. See be- agents. A complete list of authorized service agents low for size and capacities. accompanies this manual and is also posted on our company’s official website @ www.traulsen.com. Model RPP232L-FHS can accommodate two (2) sta

Inhaltszusammenfassung zur Seite Nr. 6

VII. TROUBLE SHOOTING GUIDE FIND YOUR PROBLEM HERE REMEDY 1. Unit fails to start. a. Check power supply. 2. Condensing unit operates for a. Are doors closing properly? prolonged periods or continuously. b. Dirty condenser or filter. Clean properly. c. Evaporator coil iced. Needs to defrost. d. Shortage of refrigerant, call service. 3. Food compartment is too warm. a. Check door(s) and gasket(s) for proper seal b. Perhaps a large quantity of warm food has recently be

Inhaltszusammenfassung zur Seite Nr. 7

VIII. WIRING DIAGRAM -6-

Inhaltszusammenfassung zur Seite Nr. 8

IX. WARRANTY INFORMATION STANDARD DOMESTIC WARRANTY TRAULSEN & CO., INC. warrants new equipment to the original purchaser, when installed within the United States against defective material and workmanship for one (1) year from the date of original installation. Under this warranty, TRAULSEN & CO., INC. will repair or replace, at its option, including service and labor, all parts found to be defective and subject to this warranty. The compressor part is warranted for an additional four (4) years