Inhaltszusammenfassung zur Seite Nr. 1
UNITED STATES STOVE COMPANY
“Keeping North America Warm
Since 1869”
Ashley Heritage
MODEL 5700
OWNER’S MANUAL
Please read this entire manual before installation and use of this appliance. Failure to
follow these instructions could result in property damage, bodily injury, or even death.
Contact your local building or fire officials about restrictions and installation inspection
requirements in your area.
Save these instructions.
UNITED STATES STOVE COMPANY
227 INDUSTRIAL PARK
Inhaltszusammenfassung zur Seite Nr. 2
TABLE OF CONTENTS TABLE OF CONTENTS .................................................................................................................2 SAFETY PRECAUTIONS...............................................................................................................3 SPECIFICATIONS .......................................................................................................................5 Heating Specifications.....................................................
Inhaltszusammenfassung zur Seite Nr. 3
SAFETY PRECAUTIONS IMPORTANT: Read this entire manual before Disconnect the power cord before performing installing and operating this product. Failure any maintenance! NOTE: Turning the ON/OFF to do so may result in property damage, bodily Switch to ”OFF” does not disconnect all power injury, or even death. Proper installation of to the electrical components of the stove. this stove is crucial for safe and efficient op- Never try to repair or replace any part of the eration. sto
Inhaltszusammenfassung zur Seite Nr. 4
SAFETY PRECAUTIONS Keep foreign objects out of the hopper. The moving parts of this stove are propelled by high torque electric motors. Keep all body parts away from the auger while the stove is plugged into an electrical outlet. These mov- ing parts may begin to move at any time while the stove is plugged in. Do not place clothing or other flammable items on or near this stove. When installed in a mobile home, the stove must be grounded directly to the steel chassis and bolt
Inhaltszusammenfassung zur Seite Nr. 5
SPECIFICATIONS HEATING SPECIFICATIONS 1 38,000 BTU/hr Heat Output 2 Heating Capacity 800 – 2,000 sq ft 3 Fuel Burn Rate 1.5 – 4.7 lbs/hr Burn Time (lowest setting) 24 hrs Hopper Capacity 50 lbs 1 BTU output will vary depending on the quality of fuel. Use PFI listed fuels for the best results. 2 Heating capacity will vary depending on floor plan layout of your home, degree of insulation, and the outside temperature. 3 Pellet size may effect the actual rate of fuel feed and bur
Inhaltszusammenfassung zur Seite Nr. 6
INSTALLATION INSTALLATION OPTIONS Read this entire manual before you install and use your Ashley Heritage stove. Failure to follow instructions may result in property damage, bodily injury, or even death! (See specific installation details for clearances and other installation requirements) A Freestanding Unit—supported by (4) legs and placed on a non-combustible floor surface in compliance with clearance requirements for a freestanding stove installation. An Alcove Unit—supported by
Inhaltszusammenfassung zur Seite Nr. 7
INSTALLATION CLEARANCES Your Ashley Heritage Model 5700 stove has been tested and listed for installation in residential, mobile home, and alcove applications in accordance with the clearances given in FIGURES 3-5 and TABLE 1. NOTE: Distance “C” on the right-hand side of your Ashley Heritage Model 5700 stove may need to be greater than the minimum required clearance for suitable access to the control panel. FIGURE 4 FIGURE 3 SIDEWALL CLEARANCES SIDEWALL CLEARANCES
Inhaltszusammenfassung zur Seite Nr. 8
INSTALLATION VENTING REQUIREMENTS Install vent at clearances specified by the vent manufacturer. Do not connect the pellet vent to a vent serving any other appliance or stove. Do not install a flue damper in the exhaust venting system of this unit. The following installation guidelines must be followed to ensure conformity with both the safety listing of this stove and to local building codes. IMPORTANT! This unit is equipped with a negative draft system that pulls air through the
Inhaltszusammenfassung zur Seite Nr. 9
INSTALLATION VENT TERMINATION CLEARANCES: A) Minimum 4-foot clearance below or beside any door or window that opens. B) Minimum 1-foot clearance above any door or window that opens. C) Minimum 3-foot clearance form any adjacent building. D) Minimum 7-foot clearance from any grade when adjacent to public walkways. E) Minimum 2-foot clearance above any grass, plants, or other combustible materials. F) Minimum 3-foot clearance from an forced air intake of any appliance. G) Minimum 2-foot
Inhaltszusammenfassung zur Seite Nr. 10
INSTALLATION THROUGH THE WALL INSTALLATION (RECOMMENDED INSTALLATION) To vent the unit through the wall, connect the pipe adapter to the exhaust motor adapter. If the exhaust adapter is at least 18-inches above ground level, a straight section of pellet vent pipe can be used through the wall. Your Ashley Heritage dealer should be able to pro- vide you with a kit that will handle most of this installa- tion, which will include a wall thimble that will allow the proper clearance through
Inhaltszusammenfassung zur Seite Nr. 11
INSTALLATION OUTSIDE AIR SUPPLY The use of outside air is mandatory for safe operation of this unit. For all installations it is mandatory that this unit be connected to an outside air supply . Metal pipe (solid or flexible) must be used for the outside air installation. PVC pipe is NOT approved and should NEVER be used. A wind shield over the termination of the outside air pipe or a 90-degree elbow or bend away from the prevailing winds MUST be used when an outside air pipe is inst
Inhaltszusammenfassung zur Seite Nr. 12
INSTALLATION SPECIAL MOBILE HOME REQUIREMENTS WARNING! - DO NOT INSTALL IN A SLEEPING ROOM CAUTION! - THE STRUCTURAL INTEGRITY OF THE MOBILE HOME FLOOR, WALL, AND CEILING/ ROOF MUST BE MAINTAINED. In addition to the previously detailed installation requirements, mobile home installations must meet the following requirements: • The stove must be permanently attached to the floor. • The stove must have a permanent outside air source (USSC Part No FAK1780 Fresh Air Kit is recommended
Inhaltszusammenfassung zur Seite Nr. 13
OPERATION Do not operate your stove with the viewing or ash pan doors open. The upper auger will not feed pellets under these circumstances and a safety concern may arise from sparks or fumes entering the room. This heater is designed and approved for premium hardwood pellet fuel only. Any other type of fuel burned in this heater will void the warranty and safety listing. A working smoke detector must be installed in the same room as this product. HOW YOUR STOVE WORKS Your Ashley
Inhaltszusammenfassung zur Seite Nr. 14
OPERATION CONTROL PANEL Turning the stove OFF/ON, as well as adjustments for the fuel feed rate and room air fan speed are performed by pressing the appropriate but- ton(s) on the control panel which is located on the lower right-hand side of your Ashley Heritage Model 5700 stove (see FIGURE 11). Pressing the “ON” button on the control panel will be- gin the start-up sequence for the stove. Fuel will begin to feed through the auger feed system and, once an adequate amount of fuel has
Inhaltszusammenfassung zur Seite Nr. 15
OPERATION 4) Check that both augers and the exhaust blower are operating (the room air blower will not start at this time). DO NOT open the viewing door, the auto-start igniter will get very hot during this test. The stove will auto- matically shut down after approximately 23 minutes. START-UP PROCEDURE Never use gasoline, gasoline-type lantern fuel, kerosene, charcoal lighter fluid, or similar liquids to start or ’freshen up’ a fire in this stove. Keep all such liquids well away from
Inhaltszusammenfassung zur Seite Nr. 16
OPERATION DAILY OPERATION The hopper and stove top will be hot during operation; therefore, you should always use some type of hand protection when refueling your stove. Never place your hand near the auger while the stove is in operation. This unit has a 50-pound hopper and should be filled when the hopper level drops below 3-inches. Ensure that all pellet matter is cleared from the hopper gasket surface before closing. Be sure to close hopper se- curely after refueling. Do not op
Inhaltszusammenfassung zur Seite Nr. 17
MAINTENANCE Failure to clean and maintain this unit as indicated can result in poor performance and safety haz- ards. Unplug your stove’s electrical cord prior to removing the back panel or opening the exhaust sys- tem for any inspection, cleaning, or maintenance work. Never perform any inspections, cleaning, or maintenance on a hot stove. Do not operate stove with broken glass , leakage of flue gas may result. EXHAUST SYSTEM The by products of combustion contain small particles of f
Inhaltszusammenfassung zur Seite Nr. 18
MAINTENANCE tact your Authorized “Ashley Heritage” Dealer to obtain a can of suitable high-temperature paint. GLASS We recommend using a high quality glass cleaner. Should a build up of creosote or carbon accumulate, you may wish to use 000 steel wool and water to clean the glass. In the event you need to replace the glass, only high tem- perature ceramic glass of the correct size and thickness may be used. Contact your Authorized “Ashley Heritage” Dealer to obtain this glass. FALL ST
Inhaltszusammenfassung zur Seite Nr. 19
MAINTENANCE FIGURE 12 MAINTENANCE PARTS DIAGRAM -19-
Inhaltszusammenfassung zur Seite Nr. 20
TROUBLE SHOOTING Disconnect the power cord before performing any maintenance! NOTE: Turning the ON/OFF Switch to ”OFF” does not disconnect all power to the electrical components of the stove. Never try to repair or replace any part of the stove unless instructions for doing so are given in this manual. All other work should be done by a trained technician. PROBLEM CAUSE: Too rich air/fuel mixture Orange, lazy flame—excessive • Clean out the burn plate and burn pot. fuel build-up in
