Bedienungsanleitung Wayne PC1 Series

Inhaltszusammenfassung zur Seite Nr. 1

operating Instructions & Parts Manual PC1 and PC2 Series
Please read and save these instructions. Read carefully before attemptingto assemble, install, operate or maintain the productdescribed.
Protect yourself and othersby observing all safety information. Failureto complywith instructions could result inpersonal injury and/or
property damage! Retain instructions for future reference.
Self-Priming
Transfer Pumps
Table of Contents Unpacking General Safety Information

Inhaltszusammenfassung zur Seite Nr. 2

Operating . Instructions . and . Parts . Manual 6 . .The . inlet . or . suction . hose . should . Installation IMPor Tan T BaTTery not . be . longer . than . 15 . feet; . and . Infor MaTIon the . vertical . distance . between . the . Models . PC1 . and . PC2 . include . a . 6 . foot . Be . certain . that . the . area . around . the . pump . and . the . water . level . should . long . suction . hose, . a . water . suction . batteries . is . well . ventilated .B .efore . not . be . any . higher .

Inhaltszusammenfassung zur Seite Nr. 3

PC1 and PC2 Series operation (Continued) 4 . .Connect . pump . to . power . source, . 12 VOLT WIRING DIAGRAM with . pump . in . a . dry . location .M . odel . PC1: . Motor . must . be . connected . to . a . fully . charged . automotive . tractor . or . marine . type . battery . to . operate . . . BLACK CLAMP TO NEGATIVE TERMINAL Grounding .Plug OUTLET INLET RED CLAMP TO POSITIVE TERMINAL + - TEST RESET POS NEG 12 VOLT DC BATTERY figure 1 12 VOLT DC PUMP . Connect . the . red . clamp . to . the

Inhaltszusammenfassung zur Seite Nr. 4

Operating . Instructions . and . Parts . Manual Troubleshooting Chart Symptom Possible Cause(s) Corrective a ction Pump . will . not . start . or . run 1 .B .lown . fuse 1 .I . f . blown, . replace . with . proper . sized . fuse . or . reset . breaker 2 .L .ow . line . voltage 2 .V .oltage . of . power . supply . must . match . the . voltage . of . the . pump 3 .W . orn . brushes 3 .R .eplace . brushes 4 .I . mpeller . blocked 4 .R .emove . blockage 5 .M . otor . has . overheated . . (Model . PC

Inhaltszusammenfassung zur Seite Nr. 5

PC1 and PC2 Series notes www.waynepumps.com 5

Inhaltszusammenfassung zur Seite Nr. 6

Operating . Instructions . and . Parts . Manual For Replacement Parts or Technical Assistance, Call 1-800-237-0987 Please provide following information: Address any correspondence to: - . Model . number . Wayne . Water . Systems . . - . Serial . number . (if . any) . 101 . Production . Drive - . Part . description . and . number . as . shown . in . parts . list . Harrison, . OH . . 4 . 5030 . . U . . S . A . figure  – r eplacement Parts Illustration for Self-Priming Transfer Pumps www.

Inhaltszusammenfassung zur Seite Nr. 7

PC1 and PC2 Series r eplacement Parts l ist for Self-Priming Transfer Pumps r eference Part number for Models: number Description PC1 PC2 Quantity . 1 . Brush . and . Impeller . Kit . . 66062-WYN1 . 66058-WYN1 . A . . Impeller . 1 . . B . . Gasket . 2 . C . . Shaft .S .eal . 1 . D . . Retaining . Ring . 1 . E . . Brushes . 2 . 2 . Brush . Kit . . 66063-WYN1 . — . E . . Brushes . 2 . 3 . Water . Suction . Attachment . . 66064-WYN1 . 66064-WYN1 . F . . Water . Suction . Attachment .

Inhaltszusammenfassung zur Seite Nr. 8

Operating . Instructions . and . Parts . Manual limited w arranty For . one . year . from . the . date . of . purchase, . Wayne . Water . Systems . (“Wayne”) . will . repair . or . replace, . at . its . option, . for . the . original . purchaser . any . part . or . parts . of . its . Sump . Pumps . or . Water . Pumps . (“Product”) . found . upon . examination . by .Wayne .to .be .defective .in .materials .or .workmanship . . Please .call .Wayne .(800-237-0987) .for .instructions .or .see . your