Inhaltszusammenfassung zur Seite Nr. 1
TRUE FOOD SERVICE EQUIPMENT, INC.
2001 East Terra Lane • P.O. Box 970 • O’Fallon, Missouri 63366
(636)-240-2400 • FAX (636)272-2408 • INT’L FAX (636)272-7546 • (800)325-6152
Parts Department (800)424-TRUE • Parts Department FAX# (636)272-9471
INSTALLATION MANUAL FOR GDIM
(GLASS DOOR ICE MERCHANDISERS)
TABLE OF CONTENTS
Safety Information
Safety Precautions 1
Do’s and Don’ts 2
Proper Disposal 3
Connecting Electricity 4
Adapter Plugs 4
Installation / Operation Instructions
Ownership 5
Required To
Inhaltszusammenfassung zur Seite Nr. 2
True Food Service Equipment, Inc. True Food Service Equipment, Inc. ............ www.truemfg.com ............ ............ www.truemfg.com ............
Inhaltszusammenfassung zur Seite Nr. 3
True Food Service Equipment, Inc. True Food Service Equipment, Inc. SAFETY INFORMATION SAFETY INFORMATION How to Maintain Your Freezer to Receive the Most Efficient and Successful Operation You have selected one of the finest commercial freezer units made. It is manufactured under strict quality controls with only the best quality materials available. Your TRUE freezer when properly maintained will give you many years of trouble-free service. WARNING! Use this appliance for its inte
Inhaltszusammenfassung zur Seite Nr. 4
True Food Service Equipment, Inc. True Food Service Equipment, Inc. SAFETY INFORMATION SAFETY INFORMATION 2 2 2 2 ............ www.truemfg.com ............ ............ www.truemfg.com ............
Inhaltszusammenfassung zur Seite Nr. 5
True Food Service Equipment, Inc. True Food Service Equipment, Inc. SAFETY INFORMATION SAFETY INFORMATION DANGER! RISK OF CHILD ENTRAPMENT PROPER DISPOSAL OF THE REFRIGERATOR Child entrapment and suffocation are not problems Refrigerant Disposal of the past. Junked or abandoned refrigerators are Your old refrigerator may have a cooling system still dangerous… even if they will sit for “just a few that uses “Ozone Depleting ” chemicals. If you are days.” If you are getting rid of your old refrige
Inhaltszusammenfassung zur Seite Nr. 6
True Food Service Equipment, Inc. True Food Service Equipment, Inc. SAFETY INFORMATION SAFETY INFORMATION WARNING! HOW TO CONNECT ELECTRICITY Do not, under any circumstances, cut or remove the third (ground) prong from the power cord. For personal safety, this appliance must be properly grounded. The power cord of this appliance is equipped with could cause a fire hazard from overheated wires. a 3-prong (grounding) plug which mates with a Never unplug your freezer by pulling on the power standar
Inhaltszusammenfassung zur Seite Nr. 7
True Food Service Equipment, Inc. True Food Service Equipment, Inc. INSTALLATION / OPERATION INSTRUCTIONS INSTALLATION / OPERATION INSTRUCTIONS INSTALLATION / OPERATION INSTRUCTIONS OWNERSHIP To insure that your unit works properly from the Before you start to install your True unit, carefully first day, it must be installed properly. We highly inspect it for freight damage. If damage is recommend a trained refrigeration mechanic and discovered, immediately file a claim with the electrician in
Inhaltszusammenfassung zur Seite Nr. 8
True Food Service Equipment, Inc. True Food Service Equipment, Inc. INSTALLATION / OPERATION INSTRUCTIONS INSTALLATION / OPERATION INSTRUCTIONS LOCATING Step 2 C. Carefully upright cabinet. A. Carefully lay the unit on its back to remove skid. Removing Place packing material behind cabinet as a cushion. skid from bottom of When lifting unit remember to cabinet. leave the cabinet upright for 24 hours before plugging into power source. B. Remove skid by unscrewing all base rail anchor brackets
Inhaltszusammenfassung zur Seite Nr. 9
REMOVE COVER MAKE POWER CONNECTION P True Food Service Equipment, Inc. True Food Service Equipment, Inc. INSTALLATION / OPERATION INSTRUCTIONS INSTALLATION / OPERATION INSTRUCTIONS LEVELING Step 4 D. Ensure that the drain hose or hoses are positioned in the pan. A. Set unit in its final location. Be sure there is adequate ventilation in your room. Under extreme E. Free plug and cord from inside the lower rear of heat conditions, (100°F+, 38°C+), you may want to the cooler (do not plug in). ins
Inhaltszusammenfassung zur Seite Nr. 10
True Food Service Equipment, Inc. True Food Service Equipment, Inc. INSTALLATION / OPERATION INSTRUCTIONS INSTALLATION / OPERATION INSTRUCTIONS CONDUCTORS AND CIRCUITS Wire Gauge for 2% Voltage Drop in Supply Circuits 115 Volt Distance In Feet To Center of Load Amps 20 30 40 50 60 70 80 90 100 120 140 160 2 14 14141414 14 14 14 14 14 14 14 3 14 14141414 14 14 14 14 14 14 12 4 14 14141414 14 14 14 14 12 12 12 5 14 14141414 14 14 12 12 12 10 10 6 14 14141414 14 12 12 12 10 10 10 7 14 14141414 12
Inhaltszusammenfassung zur Seite Nr. 11
True Food Service Equipment, Inc. True Food Service Equipment, Inc. INSTALLATION / OPERATION INSTRUCTIONS INSTALLATION / OPERATION INSTRUCTIONS ELECTRICAL INSTRUCTIONS Step 5 True requires that a sole use circuit be dedicated for the unit. Failure to do so voids warranty. A. Before your new unit is connected to a power supply, check the incoming voltage with a WARNING Compressor warranties are void if compressor burns voltmeter. If anything less than 100% of the rated out due to low voltage. v
Inhaltszusammenfassung zur Seite Nr. 12
True Food Service Equipment, Inc. True Food Service Equipment, Inc. INSTALLATION / OPERATION INSTRUCTIONS INSTALLATION / OPERATION INSTRUCTIONS STARTUP Step 6 NOTE If the unit is disconnected or shut off, wait five A. The compressor is ready to operate. Plug in the minutes before starting again. cooler. B. Temperature control set at No. 4 position gives RECOMMENDATION freezers an approximate temperature of 20°F - 25°F. Before loading product we recommend you run Allow unit to function several
Inhaltszusammenfassung zur Seite Nr. 13
True Food Service Equipment, Inc. True Food Service Equipment, Inc. INSTALLATION / OPERATION INSTRUCTIONS INSTALLATION / OPERATION INSTRUCTIONS FREEZERS DEFROST TIME CLOCK OPERATION (Grasslin Timer) RECOMMENDED DEFROST STEP 1 SETTINGS: Your True freezer contains a defrost system The white tabs located on the outmost area True Manufacturing has factory set your that is temperature terminated, however the of the time clock have been factory set for defrost time clock to a recommended time time
Inhaltszusammenfassung zur Seite Nr. 14
True Food Service Equipment, Inc. True Food Service Equipment, Inc. MAINTENANCE, CARE & CLEANING MAINTENANCE, CARE & CLEANING IF THE COMPRESSOR WILL Make sure capacitors are discharged 5. If the compressor has an external NOT RUN before checking. Check for continuity protector, check for continuity through 1. If there is no voltage at the between each capacitor terminal and the protector or protectors. compressor terminals, follow the wiring the case. Continuity indicates a short, All externa
Inhaltszusammenfassung zur Seite Nr. 15
True Food Service Equipment, Inc. True Food Service Equipment, Inc. MAINTENANCE, CARE & CLEANING MAINTENANCE, CARE & CLEANING 4. If all operating conditions are compartment in the top of the freezer. normal, the voltage supply at the 3. Check the compressor discharge This control is attached to the compressor terminals balanced and pressure. An abnormally high evaporator drain pan. within limits, the compressor crankcase discharge pressure can cause a loss of temperature within normal limits,
Inhaltszusammenfassung zur Seite Nr. 16
CONNECTI REMOVE CO ON VER MAKE POWER E. McCabe True Food Service Equipment, Inc. True Food Service Equipment, Inc. MAINTENANCE, CARE & CLEANING MAINTENANCE, CARE & CLEANING MAINTENANCE, CARE & CLEANING CLEANING THE CONDENSER COIL When using electrical appliances, basic safety precautions should be followed, including the following: REQUIRED TOOLS: • Phillips Screwdriver • Stiff Bristle Brush • Adjustable Wrench Step 1 Disconnect power to unit. Step 2 Take off lower grill assembly by removing fo
Inhaltszusammenfassung zur Seite Nr. 17
Condensing Unit Air Air Airflow flow flow True Food Service Equipment, Inc. True Food Service Equipment, Inc. MAINTENANCE, CARE & CLEANING MAINTENANCE, CARE & CLEANING IMPORTANT WARRANTY INFORMATION Condensers accumulate dirt and require cleaning every 30 days. Dirty condensers result in compressor failure, product loss, and lost sales... which are not covered by warranty. If you keep the Condenser clean you will minimize your service expense and lower your electrical costs. The Condenser requir
Inhaltszusammenfassung zur Seite Nr. 18
True Food Service Equipment, Inc. True Food Service Equipment, Inc. MAINTENANCE, CARE & CLEANING MAINTENANCE, CARE & CLEANING Stainless Steel Equipment Care and Cleaning CAUTION: Do not use any steel wool, abrasive or chlorine based products to clean stainless steel surfaces. Stainless Steel Opponents There are three basic things which can break down your stainless steel’s passivity layer and allow corrosion to rear its ugly head. 1) Scratches from wire brushes, scrapers, and steel pads are ju
Inhaltszusammenfassung zur Seite Nr. 19
True Food Service Equipment, Inc. True Food Service Equipment, Inc. MAINTENANCE, CARE & CLEANING MAINTENANCE, CARE & CLEANING Stainless Steel Equipment Care and Cleaning Recommended cleaners for certain situations / environments of stainless steel A) Soap, ammonia and detergent medallion applied with a cloth or sponge can be used for routine cleaning. B) Arcal 20, Lac-O-Nu Ecoshine applied provides barrier film for fingerprints and smears. C) Cameo,Talc, Zud First Impression is applied by r
Inhaltszusammenfassung zur Seite Nr. 20
TRUE REFRIGERATION TM True Food Service Equipment, Inc. True Food Service Equipment, Inc. MADE IN WARRANTY INFORMATION (U.S.A & CANADA ONLY!) WARRANTY INFORMATION (U.S.A & CANADA ONLY!) U.S.A. SINCE 1945 ONE ONE YEAR P YEAR PAR ARTS & LABOR TS & LABOR W WARRANTY ARRANTY TRUE warrants to the original purchaser of every new TRUE refrigerated unit, the cabinet and all parts thereof, to be free from defects in material or workmanship, under normal and proper use and maintenance service as specified
