Inhaltszusammenfassung zur Seite Nr. 1
OPERATOR’S
MANUAL
Baron XL / 2400 XL / RD Series
21HP Hydro Tractors
Mfg. No. Description
2690762 Simplicity Baron XL, 21HP w/ 40” Mower (CE)
2690763 Snapper RD21V40, 21HP w/ 40” Mower (CE)
2690772 Massey Ferguson 2421 XL, 20HP w/ 40” Mower (CE)
2690773 Simplicity Baron XL, 21HP 4WD w/40” Mower (CE)
2690774 Snapper RD21V40, 21HP 4WD w/40” Mower (CE)
1735268
Revision G
Original Instructions
Not for
Reproduction
Inhaltszusammenfassung zur Seite Nr. 2
Not for Reproduction
Inhaltszusammenfassung zur Seite Nr. 3
Table of Contents Safety Rules & Information.................................4 Regular Maintenance........................................20 Identification Numbers ............................................9 Maintenance Schedule..........................................20 Safety Decals ........................................................10 Check Tire Pressures............................................20 Safety Icons...........................................................11 Safety Inte
Inhaltszusammenfassung zur Seite Nr. 4
Safety Rules & Information Operating Safety Congratulations on purchasing a superior-quality piece of lawn and garden equipment. Our products are designed and manufactured to meet or exceed all industry standards for safety. Power equipment is only as safe as the operator. If it is misused, or not properly maintained, it can be dangerous! Remember, you are responsible for your safety and that of those around you. Use common sense, and think through what you are doing. If you are not sure tha
Inhaltszusammenfassung zur Seite Nr. 5
Safety Rules & Information Slope Operation You could be seriously injured or even killed if you use this unit on too steep an incline. Using the unit on a slope that is too steep or where you don’t have adequate traction can cause you to lose control or roll over. A good rule of thumb is to not operate on any slope you cannot back up (in 2-wheel drive mode). You should not operate on inclines with a slope greater than a 3.5 foot rise over a 20 foot length. Always drive up and down slopes: nev
Inhaltszusammenfassung zur Seite Nr. 6
Safety Rules and Information Read these safety rules and follow them closely. Failure to obey these rules could result in loss of control of unit, severe personal injury or death to you, or bystanders, or damage to property or equipment This mowing deck is capable of amputating hands and feet and throwing objects. The triangle in text signifies important cautions or warnings which must be followed. GENERAL OPERATION 1. Read, understand, and follow all instructions in the manual and 16. U
Inhaltszusammenfassung zur Seite Nr. 7
Safety Rules and Information SLOPE OPERATION WARNING Slopes are a major factor related to loss-of-control and tip-over Never operate on slopes greater than 17.6 percent accidents, which can result in severe injury or death. Operation on (10°) which is a rise of 3-1/2 feet (106 cm) vertically in all slopes requires extra caution. If you cannot back up the slope or 20 feet (607 cm) horizontally. if you feel uneasy on it, do not operate on it. When operating on slopes use additional wheel Control
Inhaltszusammenfassung zur Seite Nr. 8
Safety Rules & Information 11. Do not remove the fuel filter when the engine is hot as spilled SERVICE AND MAINTENANCE gasoline may ignite. Do not spread fuel line clamps further Safe Handling of Gasoline than necessary. Ensure clamps grip hoses firmly over the filter 1. Extinguish all cigarettes, cigars, pipes, and other sources of after installation. ignition. 12. Do not use gasoline containing METHANOL, gasohol 2. Use only approved gasoline containers. containing more than 10% ETHANOL, gaso
Inhaltszusammenfassung zur Seite Nr. 9
Identification Numbers CE Identification Tag Markings Identification Numbers A. Manufacturer’s Identification Number When contacting your authorized dealer for replacement parts, service, or information you MUST have these B. Manufacturer’s Serial Number numbers. C. Power Rating in Kilowatts Record your model name/number, manufacturer’s identification D. Maximum Engine Speed in Rotations per Minute numbers, and engine serial numbers in the space provided for easy access. These numbers can be fou
Inhaltszusammenfassung zur Seite Nr. 10
Safety Decals and obeyed. Personal bodily injury can result when these Safety Decals instructions are not followed. The information is for your safety This unit has been designed and manufactured to provide you and it is important! The safety decals below are on your rider with the safety and reliability you would expect from an industry and mower. leader in outdoor power equipment manufacturing. If any of these decals are lost or damaged, replace them at Although reading this manual and the saf
Inhaltszusammenfassung zur Seite Nr. 11
Safety Decals Safety Icons Warning: Read Operator’s Manual. Danger: Fire Hazard. Read and understand the Operator’s Do not add fuel while engine is hot or Manual before using this machine. running. Stop engine and allow to cool for 3 minutes prior to adding fuel. Danger: Dismemberment. Danger: Hot Surface. This machine can amputate limbs. Allow machine to cool before touching Keep bystanders and children away this area. when engine is running. Danger: Dismemberment. Danger: Carbon Monoxide Poi
Inhaltszusammenfassung zur Seite Nr. 12
Features & Controls 12V Figure 1. Tractor and Mower Controls NOTE: Steering wheel removed for clarity. Control Functions The information below briefly describes the function of individual controls. Starting, stopping, driving, and mowing require the combined use of several controls applied in specific sequences. To learn what combination and sequence of controls to use for various tasks see the OPERATION section. Throttle/Choke Control Throttle Control (Single Lever Models) The throttle control
Inhaltszusammenfassung zur Seite Nr. 13
Features & Controls Headlights Ground Speed Pedals The light switch turns the tractor headlights on and off. The tractor’s forward ground speed is controlled by the forward ground speed control pedal. The tractor’s reverse ground speed is controlled by the reverse ground speed control pedal. Brake Pedal Depressing either pedal will increase ground speed. Note that Depressing the brake pedal applies the tractor brake. the further down the pedal is depressed, the faster the tractor will trav
Inhaltszusammenfassung zur Seite Nr. 14
Features & Controls Seat Adjustment Lever Catcher Dump Lock Pedal The seat can be adjusted forward and back. Move the lever, The catcher dump lock pedal unlocks the catcher so that it can position the seat as desired, and release the lever to lock the be opened to dump out collected grass. seat into position. Catcher Open/Close Lever Transmission Release Valve Lever The catcher open/close lever opens the catcher so that it may The transmission release valve lever deactivates the be emptied and
Inhaltszusammenfassung zur Seite Nr. 15
Operating the Tractor WARNING Safety Interlock System Tests Gasoline is highly flammable and must be handled with WARNING care. Never fill the tank when the engine is still hot from recent operation. Do not allow open flame, This unit is equipped with safety interlock switches smoking or matches in the area. Avoid over-filling and and other safety devices. These safety systems are wipe up any spills. present for your safety. Do not attempt to bypass safety switches, and never tamper with safety
Inhaltszusammenfassung zur Seite Nr. 16
Operating the Tractor If an operator chooses to mow in reverse, the RMO system can Driving The Tractor be used. To use the Reverse Mowing Option (RMO) turn the 1. Sit in the seat and adjust the seat so that you can RMO key after the PTO is engaged. The L.E.D. light will comfortably reach all the controls and see the dashboard illuminate, and the operator can then mow in reverse. Each time display. the PTO is disengaged the RMO needs to be reactivated if 2. Engage the parking brake. desired.
Inhaltszusammenfassung zur Seite Nr. 17
Operating the Tractor Four Wheel Drive Models (4WD) 1. Disengage the PTO and turn the engine off. C 2. Push the transmission release in approximately 2-1/2” (6.4 cm) to lock into released position (Figure 2.2). 3. The tractor can now be pushed by hand. B A Figure 3. Engaging the Parking Brake A. Ground Speed Pedals B. Brake Pedal C. Parking Brake Knob Emptying the Catcher To empty the catcher: 1. Depress the catcher dump pedal (A, Figure 4). A 2. Extend the catcher lever (B) and use it to emp
Inhaltszusammenfassung zur Seite Nr. 18
396 Lbs. (180kg) Operating the Tractor Attaching a Trailer Catcher Removal AND Installation NOTE: Remove the hopper to attach a trailer. WARNING The maximum horizontal drawbar force allowed is 444 Newton. The maximum vertical drawbar force is 222 Newton. This Do not operate the unit without the hopper or deflector equates to a 396 lbs (180 kg) trailer on a 10 degree hill. Secure in place. the trailer with an appropriately sized clevis pin (A, Figure 5) and clip (B). 1. Move the catcher removal
Inhaltszusammenfassung zur Seite Nr. 19
Operating the Tractor 12 Volt Power Outlet Storage (certain models) WARNING CAUTION Never store the unit (with fuel) in an enclosed, poorly ventilated structure. Fuel vapors can travel to an Avoid Injury. Safe operation requires your full ignition source (such as a furnace, water heater, etc.) attention. Do not wear radio or music headphones and cause an explosion. while operating machine. Fuel vapor is also toxic to humans and animals. The 12-volt accessory plug is located in the left side pod
Inhaltszusammenfassung zur Seite Nr. 20
Regular Maintenance Maintenance Schedule The following schedule should be followed for normal care of your tractor and mower. TRACTOR AND MOWER ENGINE Every 8 Hours or Daily First 5 Hours Check safety interlock system Change engine oil - see engine manual Clean debris off tractor and mower deck Every 8 Hours or Daily Clean debris from engine compartment Check engine oil level - see engine manual Every 25 Hours or Annually * Every 25 Hours or Annually * Check mower blade stopping time Clean engi
