Inhaltszusammenfassung zur Seite Nr. 1
7021RES
Owner’s Manual
532 40 38-15 01.23.06 BY Printed in U.S.A.
Inhaltszusammenfassung zur Seite Nr. 2
SAFETY RULES Safe Operation Practices for Walk-Behind Mowers IMPORTANT: THIS CUTTING MACHINE IS CAPABLE OF AMPUTATING HANDS AND FEET AND THROW ING OBJECTS. FAILURE TO OBSERVE THE FOLLOWING SAFETY INSTRUCTIONS COULD RESULT IN SERIOUS INJURY OR DEATH. � Stop the blade(s) when crossing gravel drives, walks, Look for this symbol to point out im- or roads. por tant safety precautions. It means � Stop the engine (motor) whenever you leave the equip- CAUTION!!! BE COME ALERT!!! YOUR men
Inhaltszusammenfassung zur Seite Nr. 3
� Never refuel the machine indoors. wire away from plug to prevent accidental starting. � Never store the machine or fuel container where there � Keep nuts and bolts, especially blade attachement is an open fl ame, spark or pilot light such as a water bolts, tight and keep equipment in good condition. heater or on other appliances. � Never tamper with safety devices. Check their proper � Never fi ll containers inside a vehicle, on a truck or trailer operation regularly. bed with
Inhaltszusammenfassung zur Seite Nr. 4
ASSEMBLY Read these instructions and this man u al in its entirety before you attempt to assemble or operate your new lawn OPERATOR MOWING PRESENCE mow er. PO SI TION CONTROL IMPORTANT: THIS LAWN MOWER IS SHIPPED WITH- BAR OUT OIL OR GASOLINE IN THE ENGINE. LIFT Your new lawn mower has been as sem bled at the factory UP with the ex cep tion of those parts left unassembled for ship- ping purposes. All parts such as nuts, washers, bolts, etc., necessary to com plete the as sem bly have b
Inhaltszusammenfassung zur Seite Nr. 5
ASSEMBLY TO ASSEMBLE GRASS CATCHER TO PREPARE BATTERY (See Fig. 4) (See Fig. 3) NOTE: Your battery must be charged before you can start your lawn mower. 1. Put grass catcher frame into grass bag with rigid part of bag on the bottom. Make sure the frame handle is 1. Con nect battery charger con nec tor (male) to harness outside of the bag top. con nec tor (fe male). 2. Slip vinyl bindings over frame. 2. Plug battery charger into 110 volt A.C. outlet. NOTE: If vinyl bindings are too
Inhaltszusammenfassung zur Seite Nr. 6
OPERATION KNOW YOUR LAWN MOWER READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR LAWN MOWER. Compare the illustrations with your lawn mower to familiarize yourself with the location of various controls and adjustments. Save this manual for future reference. These symbols may appear on your lawn mower or in literature supplied with the product. Learn and understand their meaning. OPERATOR PRESENCE CON TROL BAR DRIVE CONTROL LEVER HANDLE KNOB KEY START SWITCH AUXILIARY DRI
Inhaltszusammenfassung zur Seite Nr. 7
OPERATION The operation of any lawn mower can result in foreign objects thrown into the eyes, which can result in severe eye damage. Always wear safety glasses or eye shields while operating your lawn mower or per- forming any adjustments or repairs. We recommend standard safety glasses or a wide vision safety mask over spectacles. DRIVE CONTROL ADJUSTMENT HOW TO USE YOUR LAWN MOWER Over time, the drive control system may become “loose”, ENGINE SPEED resulting in decreased speed. There is
Inhaltszusammenfassung zur Seite Nr. 8
OPERATION TO CONVERT MOWER TO ATTACH GRASS CATCHER (See Fig. 7) Your lawn mower was shipped ready to be used as a 1. Lift the rear door of the lawn mower and place the grass mulcher. To convert to bagging or discharging: catcher frame side hooks onto the door pivot pins. REAR BAGGING (See Fig. 9) 2. The grass catcher is secured to the lawn mower hous ing � Open rear door and remove mulcher plug. Store when the rear door is lowered onto the grass catcher mulcher plug in a safe place
Inhaltszusammenfassung zur Seite Nr. 9
OPERATION BEFORE STARTING ENGINE ADD OIL (See Fig. 11) Your lawnmower is shipped without oil in the engine. For type and grade of oil to use, see “EN GINE” in the Mainte- nance section of this manual. CAUTION: DO NOT overfi ll engine with oil, or it will smoke on startup. 1. Be sure lawnmower is level. 2. Remove oil dipstick from oil fi ll spout. OPEN MULCHER 3. Engine holds 20 ounces of oil. For type and grade of DOOR oil to use, see “ENGINE” in the Maintenance section of this manu
Inhaltszusammenfassung zur Seite Nr. 10
OPERATION ADD GASOLINE (See Fig. 11) MOWING TIPS � Fill fuel tank to bottom of tank fi ller neck. Do not over- CAUTION: Do not use de-thatcher blade fi ll. Use fresh, clean, regular unleaded gasoline with attachments on your mower. Such at- a minimum of 87 octane. Do not mix oil with gasoline. tachments are hazardous, will damage Purchase fuel in quan ti ties that can be used within 30 your mower and could void your warranty. days to assure fuel freshness. � Under certain conditio
Inhaltszusammenfassung zur Seite Nr. 11
MAINTENANCE BEFORE AFTER EVERY EVERY EVERY BEFORE EACH EACH 10 25 HOURS 100 STORAGE USE USE HOURS OR SEASON HOURS Check for Loose Fasteners Clean / Inspect Grass Catcher * Check Tires Check Drive Wheels *** Clean Lawn Mower **** Clean under Drive Cover *** Check Drive Belt / Pulleys *** Check / Sharpen / Replace Blade Lubrication Clean and Recharge Battery ** Check Engine Oil level Change Engine Oil Clean Air Filter Inspect Muffler Replace Spark Plug Replace Air Filter Paper Cartridge Empty fuel
Inhaltszusammenfassung zur Seite Nr. 12
MAINTENANCE LAWN MOWER BLADE ADAPTER KEY CRANKSHAFT KEY WAY Always observe safety rules when performing any main- te nance. BLADE LOCK TIRES WASHER � Keep tires free of gasoline, oil, or insect control chem- i cals which can harm rubber. � Avoid stumps, stones, deep ruts, sharp objects and other hazards that may cause tire damage. DRIVE WHEELS BLADE BOLT Check rear drive wheels each time you mow to be sure they HARDENED move freely. The wheels not turning freely means trash, TRAILIN
Inhaltszusammenfassung zur Seite Nr. 13
MAINTENANCE TO CLEAN AIR FILTER ENGINE 1. Loosen screws and re move cover. LUBRICATION 2. Carefully remove cartridge. Use only high quality detergent oil rated with API service 3. Clean by gently tapping on a fl at surface. If very dirty, classifi cation SG–SL. Select the oil's SAE viscosity grade replace car tridge. according to your expected operating temperature. SAE VISCOSITY GRADES CAUTION: Pe tro leum solvents, such as ker o sene, are not to be used to clean SAE 30 car tridge. Th
Inhaltszusammenfassung zur Seite Nr. 14
SERVICE AND ADJUSTMENTS CAUTION: TO AVOID SERIOUS INJURY, BEFORE PERFORMING ANY SERVICE OR ADJUSTMENTS: 1. Release control bar and stop engine. 2. Make sure the blade and all moving parts have completely stopped. 3. Disconnect spark plug wire from spark plug and place where it cannot come in contact with plug. LAWN MOWER CRANKSHAFT TO ADJUST CUTTING HEIGHT BLADE HOUSING ADAPTER / See “TO ADJUST CUTTING HEIGHT” in the Operation PULLEY section of this manual. REAR DEFLECTOR The rear defl
Inhaltszusammenfassung zur Seite Nr. 15
SERVICE AND ADJUSTMENTS TO ADJUST HANDLE (See Fig. 18) ENGINE The handle on your lawn mower has three (3) height posi- ENGINE SPEED tions - adjust to height that suits you. Your engine speed has been factory set. Do not attempt to � Squeeze the bottom ends of lower handle towards each increase engine speed or it may result in personal injury. If other until the pin in handle can be inserted into one you believe that the engine is running too fast or too slow, of the three height adjus
Inhaltszusammenfassung zur Seite Nr. 16
STORAGE ENGINE MOWING OPERATOR POSITION FUEL SYSTEM PRES ENCE CONTROL IMPORTANT: IT IS IMPORTANT TO PREVENT GUM BAR DEPOSITS FROM FORMING IN ESSENTIAL FUEL SYSTEM FOLD PARTS SUCH AS CARBURETOR, FUEL FILTER, FUEL HOSE, FORWARD OR TANK DURING STORAGE. ALCOHOL BLENDED FUELS FOR (CALLED GASOHOL OR USING ETHANOL OR METHANOL) STORAGE CAN ATTRACT MOISTURE WHICH LEADS TO SEPARATION AND FORMATION OF ACIDS DURING STORAGE. ACIDIC GAS CAN DAMAGE THE FUEL SYSTEM OF AN ENGINE WHILE IN STORAGE. �
Inhaltszusammenfassung zur Seite Nr. 17
TROUBLESHOOTING POINTS PROBLEM CAUSE CORRECTION Does not start 1. Dirty air fi lter. 1. Clean/replace air fi lter. 2. Out of fuel. 2. Fill fuel tank. 3. Stale fuel. 3. Empty f
Inhaltszusammenfassung zur Seite Nr. 18
18 ROTARY LAWN MOWER - - MODEL NUMBER 7021RES (96143001800) - PRODUCT NUMBER 961 43 00-18
Inhaltszusammenfassung zur Seite Nr. 19
19 ROTARY LAWN MOWER - - MODEL NUMBER 7021RES (96143001800) - PRODUCT NUMBER 961 43 00-18 KEY PART KEY PART NO. NO. DESCRIPTION NO. NO. DESCRIPTION 35 532 18 87-86 Debris Shield 1 532 19 99-82 Handle, Upper (Includes Foam Grip) 36 532 19 23-25 Screw 2 532 19 72-02 Handle, Lower 37 532 15 04-06 Bolt, Engine 3 532 18 60-53 Spring, Rear Door, RH 38 - - - Engine, Briggs & Stratton,
Inhaltszusammenfassung zur Seite Nr. 20
20 ROTARY LAWN MOWER - - MODEL NUMBER 7021RES (96143001800) - PRODUCT NUMBER 961 43 00-18
