Inhaltszusammenfassung zur Seite Nr. 1
™
GRIZZLY ZTR®
Safety Instructions & Operator’s Manual
Model Year 2005
Inhaltszusammenfassung zur Seite Nr. 2
IMPORTANT - READ CAREFULLY The Dixon® ZTR® mower is both easy and fun to operate. However, any power mower must be operated properly to be safe. It is not a toy or a recreational vehicle. Before you start to use the mower, read this Operator’s Manual carefully. It contains valuable information that is necessary for the safe operation of the machine. Observe all safety rules and become completely familiar with the controls. The information contained in this manual applies to all Dixon® Grizz
Inhaltszusammenfassung zur Seite Nr. 3
TABLE OF CONTENTS Page SAFETY & WARNING....................................4 -15 WARRANTY.........................................................16 SPECIFICATIONS..............................................17 SEAT ADJUSTMENT .........................................18 CONTROLS..................................................19-21 OPERATION INSTRUCTIONS....................22-32 CARE & MAINTENANCE............................33-47 TROUBLESHOOTING..................................48-49 STANDARD
Inhaltszusammenfassung zur Seite Nr. 4
SAFETY RIDING LAWN MOWERS, IF IMPROPERLY OPERATED CAN CAUSE SERIOUS INJURY OR DEATH Pictured below are the most common causes of injury to the operator or bystander. Please read and understand this manual to prevent injuries. Blade Contact Tip Over Run Over Back Over 4
Inhaltszusammenfassung zur Seite Nr. 5
SAFETY Safety Alert Symbol When you see this symbol, BE ALERT to the potential for injury. Follow the recommended safety precautions and safe operating practices. DANGER (highlighted in red) indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury. WARNING (highlighted in orange) indicates a potentially hazardous situation which, if not avoided, could result in death or serious injury. CAUTION (highlighted in yellow) indicates a potentia
Inhaltszusammenfassung zur Seite Nr. 6
WARNING Failure to observe the following safety instructions could result in serious injury or death. GENERAL OPERATION: Read, understand, and follow all instructions in this manual and on the mower before starting. Only allow responsible adults, who are familiar with the instructions, to operate the mower. Clear the area of objects such as rocks, toys, wire, etc., which could be picked up and thrown by the blade. Be sure the area is clear of other people before mowing. Stop mower if anyone ente
Inhaltszusammenfassung zur Seite Nr. 7
WARNING Failure to observe the following safety instructions could result in serious injury or death. GENERAL OPERATION (continued): Never leave a running mower unattended. Always turn off blades, set parking brake, stop engine and remove key before dismounting. Turn off blades when not mowing. Injury could occur from contact with moving parts. Under no circumstances should you place hands or feet under the mower deck or in the chute while blades or impeller are still running. To avoid person
Inhaltszusammenfassung zur Seite Nr. 8
WARNING Failure to observe the following safety instructions could result in serious injury or death. GENERAL OPERATION (continued): Protect your eyes. Always wear safety goggles or safety glasses with side shields when operating mower. Data indicates that operators, age 60 years and above, are involved in a large percentage of riding mower- related injuries. These operators should evaluate their ability to operate the riding mower safely enough to protect themselves and others from serious inju
Inhaltszusammenfassung zur Seite Nr. 9
WARNING Failure to observe the following safety instructions could result in serious injury or death. SLOPE OPERATION: Slopes are a major factor related to loss-of-control and tip-over accidents, which can result in severe injury or death. All slopes require extra caution. If you feel uneasy on a slope, do not mow it! DO Mow across the slope with your Dixon® ZTR® -- never up or down. This will decrease the risk of tip-over. Remove obstacles such as rocks, tree limbs, wires and other foreign obje
Inhaltszusammenfassung zur Seite Nr. 10
WARNING Failure to observe the following safety instructions could result in serious injury or death. SLOPE OPERATION (continued): DO (continued): Keep all movement on the slopes slow and gradual. Do not make sudden changes in speed or direction. Use extreme caution when operating the mower with attachments to prevent tip-over or roll-over. If front wheels lift off the ground, pull levers back to stabilize the mower. Discontinue mowing the slope! 10
Inhaltszusammenfassung zur Seite Nr. 11
WARNING Failure to observe the following safety instructions could result in serious injury or death. SLOPE OPERATION (continued): DO NOT Do not turn on slopes unless necessary, and then, turn slowly and gradually downhill, if possible. Rapid uphill turns may cause tip-over. Do not mow near drop-offs, ditches, or embank- ments. The mower could suddenly turn over if a wheel is over the edge of a cliff or ditch or if an edge caves in. Do not mow on wet grass. Reduced traction could cause sliding.
Inhaltszusammenfassung zur Seite Nr. 12
WARNING Failure to observe the following safety instructions could result in serious injury or death. FIRE HAZARDS: Use extra care when handling gasoline and other fuels. They are flammable and vapors are explosive. Store all fuel in approved containers specifically designed for that purpose. Allow engine to cool before refueling. Never remove fuel cap or add fuel with engine running. Do not smoke while refueling or operating the mower. To reduce fire hazard, keep mower free of grass, leaves and
Inhaltszusammenfassung zur Seite Nr. 13
WARNING Failure to observe the following safety instructions could result in serious injury or death. FIRE HAZARDS (continued): To prevent fire or explosion, keep sparks and open flames away from battery. Keep electrical connections clean and tight. Inspect them often. Loose connections and corrosion increase fire risk. Before disconnecting the negative ground cable, make sure all switches are off. This decreases the chance of sparking and fire. Use care when backing to avoid pushing the grass b
Inhaltszusammenfassung zur Seite Nr. 14
WARNING Failure to observe the following safety instructions could result in serious injury or death. CHILDREN: Tragic accidents can occur if the operator is not alert to the presence of children. Children are attracted to lawn mowers and the mowing activity. NEVER assume children will stay where they were last seen. Be alert to avoid accidents. Keep children out of the mowing area and under the watchful care of another responsible adult. Be alert and turn mower off if a child enters the area.
Inhaltszusammenfassung zur Seite Nr. 15
WARNING Failure to observe the following safety instructions could result in serious injury or death. SERVICE: Never run a mower inside a closed area or without proper ventilation. Keep nuts and bolts tight, especially blade attachment bolts, and keep equipment in good condition. Never tamper with safety devices. Check their proper operation regularly. Stop and inspect the equipment if you strike an object. Repair, if necessary, before restarting. Never make adjustments or repairs with the engin
Inhaltszusammenfassung zur Seite Nr. 16
DIXON® ZTR® PRO SERIES COMMERCIAL/RESIDENTIAL WARRANTY POLICY Kodiak™, Grizzly™ & SilverTip™ Mowers DIXON® WARRANTS ITS ZTR® MOWERS AGAINST DEFECTS IN MATERIAL AND WORKMANSHIP FOR THE PERIODS SET FORTH BELOW. THE SOLE REMEDY UNDER THIS WARRANTY IS REPLACEMENT OR REPAIR OF PARTS INCLUDING LABOR COSTS. THIS WARRANTY IS SUBJECT TO THE FOLLOWING CONDITIONS AND LIMITATIONS: 1. COMMERCIAL WARRANTY (use other than, or in addition to, mowing at owner’s primary place of residence): a. First two years - 1
Inhaltszusammenfassung zur Seite Nr. 17
SPECIFICATIONS GRIZZLY™ CHASSIS: 11 GA - rectangular tube SEAT: Big Rig™ Seat Suspension System Designed for operator comfort by use of high-density closed cell foam padded back and TM arm rests, upholstered with Cordura water-repellent fabric. Seat is adjustable fore and aft. Mounted on operator suspension system. MOWER DECK: Made of 11 GA fabricated welded construction with external reinforcement ribs. Three blades combine for either a 50” or 60” cut width. Cut height approximately 1.5” to
Inhaltszusammenfassung zur Seite Nr. 18
SEAT ADJUSTMENT INSTRUCTIONS 1. Grasp seat slide adjuster and move it into adjustment position. 2. Slide seat forward or backward. 3. Release seat slide adjuster. Seat Slide Adjuster 18
Inhaltszusammenfassung zur Seite Nr. 19
CONTROLS CONTROL LEVERS Note: For access to the seat, move control levers to neutral position and swing them outward. TO GO FORWARD From neutral position, gently push control levers for- ward. T o increase speed, move levers further forward. TO GO BACKWARDS From neutral position, gently pull control levers toward you. TURNING Turning is controlled by moving one control lever slightly forward or rearward of the other. To turn left, move left lever rearward of the right lever. To turn right
Inhaltszusammenfassung zur Seite Nr. 20
CONTROLS PARKING BRAKE: The parking brake is designed to hold the mower from moving and is not intended for use in stopping the mower while it is in motion. The engine will stop if the parking brake is engaged while the control levers are in the drive position. Engage parking brake CAUTION before starting engine. TO SET PARKING BRAKE: The hand operated parking brake is located on the left hand side of the mower. To engage brake, pull lever up (to the rear). To release brake, move lever
