Inhaltszusammenfassung zur Seite Nr. 1
S10L-9626-00
IBM Mobile Systems
ThinkPad 390/i Series 1700 (2626, 2627)
Hardware Maintenance Manual
November 1998
Inhaltszusammenfassung zur Seite Nr. 2
Before using this information and the product it supports, be sure to read the general information under “Read This First” on page 19. First Edition (November 1998) The following paragraph does not apply to the United Kingdom or any country where such provisions are inconsistent with local law: INTERNATIONAL BUSINESS MACHINES CORPO- RATION PROVIDES THIS PUBLICATION "AS IS" WITHOUT ANY WARRANTY OF ANY KIND, EITHER EXPRESS OR IMPLIED, INCLUDING, BUT NOT LIMITED TO, THE LIMITED WARRANTIES OF MERC
Inhaltszusammenfassung zur Seite Nr. 3
Related Publications The following product publications are available through IBM or your IBM Authorized Dealer. Publication Part, Form Number Mobile Systems HMM 30H2356, S82G-1501-01 Volume 1: Laptop, Note- book, Portable, and ThinkPad Computers (Models L40, CL57, N45, N51, P70/P75, ThinkPad 300, 350, 500, 510, 710T, Expansion Unit, Dock I, Dock II) Mobile Systems HMM 30H2357, S82G-1502-03 Volume 2: ThinkPad Com- puters (Models 340, 355, 360, 370, 700, 701, 720, 750, 755) Mobile Systems HMM 8
Inhaltszusammenfassung zur Seite Nr. 4
Related Diskettes The following diskettes are available through IBM or your IBM Authorized Dealer. Diskette Part, Form Number ThinkPad 300 (2615) 33G9361, S33G-9361 Advanced Diagnostics Diskette ThinkPad 350, 350C, 425, A211000, GA21-1000 425C (2618) Advanced Diagnostics Diskette ThinkPad 365 (2625) 76H7578, S30H-2498 Advanced Diagnostics Diskette ThinkPad 380/385 (2635) 06J0333, S06J-0333 Maintenance Diskette ThinkPad 390/i Series 1700 10L9942, S10L-9942 (2626, 2627) Diagnostic and Utilities
Inhaltszusammenfassung zur Seite Nr. 5
Contents Introduction . . . . . . . . . . . . . . . . . . . 1 Important Service Information ........... 1 How to Use Error Messages .......... 2 How to Read POST Error Messages ...... 2 Drive and Diskette Compatibility Matrix ....... 3 Safety Notices (Multi-lingual Translations) ..... 4 Safety Information . . . . . . . . . . . . . . . . 11 General Safety . . . . . . . . . . . . . . . . 11 Electrical Safety . . . . . . . . . . . . . . . . 12 Safety Inspection Guide ............ 13 Handling El
Inhaltszusammenfassung zur Seite Nr. 6
Writing the VPD Data ............. 41 Flash UUID . . . . . . . . . . . . . . . . . . 42 Running the Diagnostics .............. 42 PQA System Diagnostics ............ 42 Audio Resource and Speaker-out Test ..... 45 PCMCIA WrapCard Test ............ 46 Modem Dial and Data Transfer Test ...... 46 FIR Data Transfer Test ............. 46 USB Connect/Disconnect Test ......... 46 Fan Diagnostics . . . . . . . . . . . . . . . . 46 FRU Removals and Replacements ......... 47 FRU Service Procedures .....
Inhaltszusammenfassung zur Seite Nr. 7
LCD FPC ASM 12.1" .............. 81 Switch Location . . . . . . . . . . . . . . . . 82 System Unit Parts Listing ............. 83 LCD Unit Parts Listing ............... 88 12.1" LCD ASM Parts Listing .......... 88 13.3" LCD ASM Parts Listing .......... 89 14.1" LCD ASM Parts Listing .......... 90 Notices . . . . . . . . . . . . . . . . . . . . . . 92 Trademarks . . . . . . . . . . . . . . . . . . . 92 Contents vii
Inhaltszusammenfassung zur Seite Nr. 8
viii ThinkPad 390/i Series 1700
Inhaltszusammenfassung zur Seite Nr. 9
Introduction Important Service Information Important Diskette fixes are customer installable. The diskette fixes are located on the PC Company Bulletin Board Service (BBS). The direct phone line for modem con- nection is 919-557-0001 or tieline 255-0001. Advise customers to contact the PC Company HelpCenter at 800-772-2227 if they need assistance in obtaining or installing any diskette fixes. Customers in Canada should call IBM HelpPC at 800-565-3344 for assistance or down-load information.
Inhaltszusammenfassung zur Seite Nr. 10
Attention A customized setup configuration (other than default settings) may exist on the computer you are servicing. Running Automatic Configuration may alter those set- tings. Note the current configuration settings (using the View Configuration option) and verify that the set- tings are in place when service is complete. Hard Disk Drive Replacement Strategy: Always try to run a low-level format before replacing a hard disk drive. Attention The drive startup sequence in the computer you ar
Inhaltszusammenfassung zur Seite Nr. 11
Drive and Diskette Compatibility Matrix The following table provides identification information for 3.5-inch drives. Diskette Identifying Drive Mark 3.5-Inch - 1.44MB 1.44 on the eject button 3.5-Inch - 2.88MB 2.88 on the eject button The following table provides compatibility information for 3.5-inch diskettes and 3.5-inch diskette drives. Diskette 1.44MB 2.88MB Capacity Drive Drive 1.0MB Read/Write Read/Write 2.0MB Read/Write Read/Write 4.0MB Not Compatible Read/Write The following tabl
Inhaltszusammenfassung zur Seite Nr. 12
Safety Notices (Multi-lingual Translations) In this manual, safety notices appear in English with a page number reference to the appropriate multi-lingual, translated safety notice found in this section. The following safety notices are provided in English, French, German, Italian, and Spanish languages. Safety Notice 1 Before the computer is powered-on after FRU replace- ment, make sure all screws, springs, or other small parts are in place and are not left loose inside the computer. Verify thi
Inhaltszusammenfassung zur Seite Nr. 13
Safety Notice 2 Some standby batteries contain a small amount of nickel and cadmium. Do not disassemble it, recharge it, throw it into fire or water, or short-circuit it. Dispose of the battery as required by local ordinances or regu- lations. Use only the battery in the appropriate parts listing. Use of an incorrect battery can result in ignition or explosion of the battery. Certaines batteries de secours contiennent du nickel et du cadmium. Ne les démontez pas, ne les rechargez pas, ne les exp
Inhaltszusammenfassung zur Seite Nr. 14
Safety Notice 3 The battery pack contains small amounts of nickel. Do not disassemble it, throw it into fire or water, or short-circuit it. Dispose of the battery pack as required by local ordinances or regulations. Use only the battery in the appropriate parts listing when replacing the battery pack. Use of an incorrect battery can result in ignition or explosion of the battery. La batterie contient du nickel. Ne la démontez pas, ne l'exposez ni au feu ni à l'eau. Ne la mettez pas en court-circ
Inhaltszusammenfassung zur Seite Nr. 15
Safety Notice 4 The lithium battery can cause a fire, explosion, or severe burn. Do not recharge it, remove its polarized connector, disassemble it, heat it above 100°C (212°F), incinerate it, or expose its cell contents to water. Dispose of the battery as required by local ordinances or regulations. Use only the battery in the appropriate parts listing. Use of an incorrect battery can result in ignition or explosion of the battery. La pile de sauvegarde contient du lithium. Elle présente des ri
Inhaltszusammenfassung zur Seite Nr. 16
Safety Notice 5 If the LCD breaks and the fluid from inside the LCD gets into your eyes or on your hands, immediately wash the affected areas with water for at least 15 minutes. Seek medical care if any symptoms from the fluid are present after washing. Si le panneau d'affichage à cristaux liquides se brise et que vous recevez dans les yeux ou sur les mains une partie du fluide, rincez-les abondamment pendant au moins quinze minutes. Consultez un médecin si des symptômes persistent après le lava
Inhaltszusammenfassung zur Seite Nr. 17
Safety Notice 6 To avoid shock, do not remove the plastic cover that surrounds the lower portion of the inverter card. Afin d'éviter tout risque de choc électrique, ne retirez pas le cache en plastique protégeant la partie inférieure de la carte d'alimentation. Aus Sicherheitsgründen die Kunststoffabdeckung, die den unteren Teil der Spannungswandlerplatine umgibt, nicht entfernen. Per evitare scosse elettriche, non rimuovere la copertura in plastica che avvolge la parte inferiore della scheda in
Inhaltszusammenfassung zur Seite Nr. 18
Safety Notice 8 Before removing any FRU, power-off the computer, unplug all power cords from electrical outlets, remove the battery pack, then disconnect any interconnecting cables. Avant de retirer une unité remplaçable en clientèle, mettez le système hors tension, débranchez tous les cordons d'alimentation des socles de prise de courant, retirez la batterie et déconnectez tous les cordons d'interface. Die Stromzufuhr muß abgeschaltet, alle Stromkabel aus der Steckdose gezogen, der Akku entfern
Inhaltszusammenfassung zur Seite Nr. 19
Safety Information The following section contains the safety information that you need to be familiar with before servicing an IBM mobile computer. General Safety Follow these rules to ensure general safety: Observe good housekeeping in the area of the machines during and after maintenance. When lifting any heavy object: 1. Ensure you can stand safely without slipping. 2. Distribute the weight of the object equally between your feet. 3. Use a slow lifting force. Never move suddenly or twi
Inhaltszusammenfassung zur Seite Nr. 20
Electrical Safety Observe the following rules when working on electrical equipment. Important Use only approved tools and test equipment. Some hand tools have handles covered with a soft material that does not insulate you when working with live elec- trical currents. Many customers have, near their equipment, rubber floor mats that contain small conductive fibers to decrease electrostatic discharges. Do not use this type of mat to protect yourself from electrical shock. Find the room emerg
