Inhaltszusammenfassung zur Seite Nr. 1
Operating & Maintenance
Instructions
Model Series
Covered in
This Manual
11A600
110600
111600
120600
121600
122600
123600
124600
125600
126600
Model Type Code
Note: General Model Series numbers noted above include many specific numbers
Month Day Year
like the ones on your engine. To get replacement parts or technical assistance in
the future, write your engine Model, Type, Code and date of purchase here.
TABLE OF CONTENTS
WARNING
Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Inhaltszusammenfassung zur Seite Nr. 2
THE POWER IN POWER EQUIPMENT Thank you for selecting a Briggs & Stratton engine to power your equipment. Briggs & Stratton is committed to producing a line of engines which will make your life’s chores easier to perform. We have, at the same time, improved the design of our engines so they are environmentally friendly. Since 1995, we have succeeded in reducing smog-forming exhaust emissions from our engines by 70%. Briggs & Stratton’s efforts have not stopped there. We are also committed to des
Inhaltszusammenfassung zur Seite Nr. 3
274264 BEFORE OPERATING ENGINE • Read entire Operating & Maintenance Instructions AND the instructions for the equipment this engine powers.* • Failure to follow instructions could result in serious injury or death. THE OPERATING & MAINTENANCE INSTRUCTIONS CONTAIN SAFETY INFORMATION TO • Make you aware of hazards associated with engines • Inform you of the risk of injury associated with those hazards, and • Tell you how to avoid or reduce the risk of injury. The safety alert symbol ( ) is used t
Inhaltszusammenfassung zur Seite Nr. 4
SAFETY WARNING WARNING Gasoline and its vapors are extremely flammable Unintentional sparking can result in fire or electric and explosive. shock. Fire or explosion can cause severe burns or death. Unintentional start-up can result in entanglement, traumatic amputation, or laceration. WHEN ADDING FUEL • Turn engine OFF and let engine cool at least 2 BEFORE PERFORMING ADJUSTMENTS OR minutes before removing gas cap. REPAIRS • Fill fuel tank outdoors or in well-ventilated area. • Disconnect spark p
Inhaltszusammenfassung zur Seite Nr. 5
SAFETY WARNING WARNING Engines give off carbon monoxide, an odorless, Rotating parts can contact or entangle hands, feet, colorless, poison gas. hair, clothing, or accessories. Breathing carbon monoxide can cause nausea, Traumatic amputation or severe laceration can fainting or death. result. • Start and run engine outdoors. • Operate equipment with guards in place. • Do not start or run engine in enclosed area, even if • Keep hands and feet away from rotating parts. doors or windows are open. •
Inhaltszusammenfassung zur Seite Nr. 6
ENGINE PARTS 7 3 4 13 2 8 12 11 9 1 5 6 10 1. Primer bulb 7. Rope handle 2. Air cleaner 8. Fuel tank 3. Fuel fill 9. Oil fill/Dipstick 4. Finger guard 10. Side drain plug (if equipped) 5. Spark plug wire 11. Muffler/Muffler guard (if equipped) 6. Carburetor 12. Spark arrester (if equipped) 13. Engine Model Type Code xxxxx xxxx xx xxxxxxxx GENERAL INFORMATION THE INTERNATIONAL SYMBOLS USED ENGINE MODEL ON THE ENGINE OR This is a single cylinder, overhead valve (OHV), air-cooled IN THIS MANUAL INC
Inhaltszusammenfassung zur Seite Nr. 7
274264 OIL SAE Viscosity Grades CAUTION: This engine is shipped from Briggs & Stratton without oil. Check oil level before starting engine. If you start the engine without oil, the engine ** will be damaged beyond repair and will not be * covered under warranty. OIL CAPACITY -20 0 20 32 40 60 80 100 °F Engine holds approximately 2/3 quart (22 ounces; 0.65 liter). -30 -20 -10 0 10 20 30 40 °C TYPE OF OIL TO USE STARTING TEMPERATURE RANGE ANTICIPATED BEFORE NEXT OIL CHANGE • Use a high quality det
Inhaltszusammenfassung zur Seite Nr. 8
FUEL • This engine is certified to operate on gasoline. Exhaust TYPE OF FUEL TO USE Emission Control System: EM (Engine Modifications). •Use clean, fresh, regular unleaded gasoline with a minimum of 85 octane. Fresh fuel prevents gum from forming in the fuel system or on essential carburetor parts. CAUTION: Some fuels, called oxygenated or reformu- Purchase fuel in quantity that can be used within 30 days. lated gasoline, are gasoline blended with alcohols or • Do not use gasoline which contains
Inhaltszusammenfassung zur Seite Nr. 9
STARTING AND STOPPING REWIND (MANUAL) STARTER TO START ENGINE Primer Choke [1] Check oil level (see p. 7). [3] Move throttle to FAST (if equipped). [5] Firmly push primer bulb 3 times OR Operate engine with throttle in FAST [2] Open fuel shut-off valve [6] Rotate choke knob or move choke (if equipped) 1/4 turn. [4] Push stop switch (if equipped) to ON. control lever to CHOKE position. [9] Let engine warm up. Choke Equipped: Rota- te knob or move choke control lever toward RUN a short distance
Inhaltszusammenfassung zur Seite Nr. 10
STARTING AND STOPPING ELECTRIC (KEY) STARTER (if equipped) TO START ENGINE Primer Choke [3] Move throttle to FAST (if [1] Check oil level (see p. 7). equipped). Operate en- [4] Firmly push primer bulb 3 times OR [2] Open fuel shut-off valve gine with throttle in rotate choke knob or move choke control (if equipped) 1/4 turn. FAST position. lever to CHOKE position. [7] Let engine warm up. Choke Equipped: Move choke control lever toward RUN a short dis- tance at a time over sev- eral seconds
Inhaltszusammenfassung zur Seite Nr. 11
MAINTENANCE MAINTENANCE EMISSION CONTROL Regular maintenance will improve the performance and Maintenance, replacement or repair of the emission extend the life of the engine. See any Authorized Briggs & control devices and systems may be performed by any Stratton Dealer for service. Use only genuine Briggs & nonroad engine repair establishment or individual. Stratton parts. Other parts may not perform as well, However, to obtain no charge repairs under the terms and may damage the engine, and m
Inhaltszusammenfassung zur Seite Nr. 12
MAINTENANCE CLEANING Flat/Oval Pre-Cleaners and Cartridges CHANGING OIL FILTER (if equipped) CAUTION: Do not use pressurized air or solvents to Replace oil filter after every 100 hours of operation. clean cartridge. Pressurized air can damage cartridge; solvents will dissolve cartridge. Pre-cleaner To clean pre-cleaner (if equipped), separate it from cartridge and wash in liquid detergent and water. Air dry thoroughly. Do not oil pre-cleaner. Re-assemble dry pre-cleaner on clean cartridge. Cartr
Inhaltszusammenfassung zur Seite Nr. 13
MAINTENANCE ENGINE AND ENGINE PARTS We recommend that you see an authorized Briggs & Stratton Service Dealer for all maintenance and service of the engine and engine parts. Use only genuine Briggs & Stratton parts. If you perform any maintenance on the engine, first disconnect the spark plug wire from the spark plug, and disconnect the battery at the negative terminal (electric WARNING starter engines only) to prevent unintentional sparking. Unintentional sparking can result in fire or electric
Inhaltszusammenfassung zur Seite Nr. 14
ADJUSTMENTS THROTTLE ADJUSTMENT CARBURETOR ADJUSTMENT If the engine does not start or if it runs roughly, the remote throttle control may need adjustment. See your authorized WARNING Briggs & Stratton dealer or follow the instructions below. The manufacturer of the equipment on which this engine is installed specifies top speed at which the WARNING engine will be operated. DO NOT EXCEED this speed. Fuel/air mixture on this engine is not adjustable. If speed adjustment is required, see your Autho
Inhaltszusammenfassung zur Seite Nr. 15
SERVICE & STORAGE An illustrated shop manual includes com- PARTIAL LIST OF GENUINE BRIGGS & mon specifications and detailed informa- STRATTON PARTS tion covering adjustment, tune-up and repair of Briggs & Stratton single cylinder, OHV, 4 cycle engines. It is available for BRIGGS & STRATTON purchase from an Authorized Briggs & PART PART NO. (or equivalent) Stratton Service Dealer or you can order it from the factory. Write: Flat air cleaner cartridge 491588 (5043) Briggs & Stratton Corporation Fl
Inhaltszusammenfassung zur Seite Nr. 16
SERVICE & STORAGE [2] While engine is still warm, change oil. STORAGE Engines stored over 30 days need special attention. [3] Remove spark plug and pour about 1/2 oz. (15 ml) of [1] To prevent gum from forming in fuel system or on engine oil into cylinder. Replace spark plug and crank essential carburetor parts: slowly to distribute oil. a) if fuel tank contains oxygenated or reformulated gasoline (gasoline blended with an alcohol or an [4] Clean engine of surface debris, chaff or grass. ether),
Inhaltszusammenfassung zur Seite Nr. 17
Briggs & Stratton Corporation (B&S), the California Air Resources Board (CARB) and the United States Environmental Protection Agency (U.S. EPA) Emission Control System Warranty Statement (Owner’s Defect Warranty Rights and Obligations) EMISSION CONTROL WARRANTY COVERAGE IS APPLICABLE TO CERTIFIED MODEL YEAR 1997 AND LATER ENGINES TO CERTIFIED ENGINES PURCHASED IN CALIFORNIA IN 1995 WHICH ARE PURCHASED AND USED ELSEWHERE IN THE AND THEREAFTER, WHICH ARE USED IN CALIFORNIA, AND UNITED STATES. Cali
Inhaltszusammenfassung zur Seite Nr. 18
About your engine warranty: (see next page for statement of LIMITED WARRANTY). Briggs & Stratton welcomes warranty repair and apologizes 4. Parts which are scored or broken because an engine was to you for being inconvenienced. Any Authorized Service operated with insufficient or contaminated lubricating oil, Dealer may perform warranty repairs. Most warranty repairs or an incorrect grade of lubricating oil (check oil level daily are handled routinely, but sometimes requests for warranty or afte
Inhaltszusammenfassung zur Seite Nr. 19
BRIGGS & STRATTON ENGINE OWNER WARRANTY POLICY effective July 1, 1999 Replaces all undated Warranties and all Warranties dated before July 1, 1999 LIMITED WARRANTY “Briggs & Stratton Corporation will repair or replace, free of charge, any part, or parts of the engine that are defective in material or workmanship or both. Transportation charges on parts submitted for repair or replacement under this Warranty must be borne by purchaser. This warranty is effective for the time periods and subject t
Inhaltszusammenfassung zur Seite Nr. 20
