Inhaltszusammenfassung zur Seite Nr. 1
gaS griLL
LP Gas Grill Owner’s Guide
Guía del propietario del asador de gas licuado de propano - pg 22
Guide de l’utilisateur du grill à gaz pl - pg 40
620
#89173
#00000
You must read this owner’s Guide
m warninG: follow all leak-check
before operatinG Your Gas Grill.
procedures carefully in this manual prior
to barbecue operation. do this even if
the barbecue was dealer-assembled.
m danGer
if you smell gas:
1. shut off gas to the appliance.
notiCe to installer: these instructions
2. ex
Inhaltszusammenfassung zur Seite Nr. 2
WarningS DangErS anD WarningS m danGer failure to follow the dangers, warnings and Cautions contained in this owner’s manual may result in serious bodily injury or death, or in a fire or an explosion causing damage to property. m warninGs m do not store a spare or disconnected liquid propane cylinder under or near this barbecue. m improper assembly may be dangerous. please follow the assembly instructions carefully. ® m after a period of storage, and/or nonuse, the weber gas barbecue should be
Inhaltszusammenfassung zur Seite Nr. 3
Warranty, garantía, garantiE ® Weber-Stephen Products Co. (Weber) hereby warrants to the ORIGINAL PURCHASER of this Weber service, or failure to perform normal and routine maintenance, including but not limited to damage Warranty gas grill that it will be free of defects in material and workmanship from the date of purchase as follows: caused by insects within the burner tubes, as set out in this owner’s manual. 3 Deterioration or damage due to severe weather conditions such as hail, hurricane
Inhaltszusammenfassung zur Seite Nr. 4
ExPLoDED viEW 620 Vision éClatée, diaGrama de despieCe SUMMIT 620_LP_US_092809 1 2 3 4 5 6 7 8 9 10 11 12 13 27 14 28 15 29 16 30 31 17 32 18 19 33 20 21 22 34 35 36 37 23 38 39 24 40 25 26 41 42 43 44 4
Inhaltszusammenfassung zur Seite Nr. 5
ExPLoDED viEW LiSt 620 lista del diaGrama de despieCe, liste de la Vision éClatée 5 1. shroud hardware 16. Knob 31. hose / regulator Accesorios de la cubierta Perilla Manguera / Regulador Structure de protection Bouton Tuyau/Régulateur 2. shroud 17. water baffle / heat shield 32. side burner lid Cubierta Reflector de agua / Pantalla térmica Tapa del quemador lateral Tôle de protection Protection contre l’eau/Cloison anti-chaleur Couvercle du brûleur latéral 3. thermometer 18. disposable drip pa
Inhaltszusammenfassung zur Seite Nr. 6
gEnEraL inStrUctionS ® ® ® Your Weber gas barbecue is a portable outdoor cooking appliance. With the Weber m warninG: Your weber gas barbecue shall not be used gas barbecue you can grill, barbecue, roast and bake with results that are difficult to under overhead combustible construction. ® duplicate with indoor kitchen appliances. The closed lid and Flavorizer Bars produce ® m warninG: Your weber gas barbecue is not intended to be that “outdoor” flavor in the food. ® The Weber gas barbecue
Inhaltszusammenfassung zur Seite Nr. 7
gEnEraL inStrUctionS slide out bottom tray - Remove excess grease, then wash with warm soapy water, do not use cleaners that contain acid, mineral spirits or xylene. rinse well after then rinse. cleaning. 7 ® flavorizer bars and Cooking grates - Clean with a suitable stainless steel bristle preserve Your stainless steel - Your grill or its cabinet, lid, control panel and shelves brush. As needed, remove from grill and wash with warm soapy water, then rinse with may be made from stainless s
Inhaltszusammenfassung zur Seite Nr. 8
a gaS inStrUctionS to ConneCt the hose to the CYlinder: A) Locate hose retention clip (1) on regulator hose. Secure into slot (2) on underside of tank scale. 1 m warninG: the hose must be secured to the tank scale 2 with the hose retention Clip. failure to do so could cause damage to the hose resulting in a fire or explosion which can cause serious bodily injury or death, and damage to property. Some LP tanks have differing top collar assembles. (The top collar is the metal protective r
Inhaltszusammenfassung zur Seite Nr. 9
gaS inStrUctionS CheCK for Gas leaKs ® 9 m warninG: the gas connections of your summit gas grill have been factory tested. we do however recommend that you leak check all gas connections before operating your ® summit gas grill. remoVe Control panel Tool required: Phillips Screwdriver. A) Remove the burner control knobs (1). B) Remove the two screws that secure the control panel to the frame (2). C) Remove the control panel (3). Tilt panel forward and lift up and away from grill. Completel
Inhaltszusammenfassung zur Seite Nr. 10
gaS inStrUctionS CheCK: A) Bulkhead and gas supply hose connection (1). 620 1 B) Main gas line to manifold connections (2). m warninG: if there is a leak at connection (1, or 2), retighten the fitting with a wrench and recheck for leaks with soap and water solution. if a leak persists after re-tightening the fitting, turn off the gas. do not operate the Grill. Contact the Customer service representative in your area using the contact information on ® our web site. log onto www.weber.com .
Inhaltszusammenfassung zur Seite Nr. 11
gaS inStrUctionS gaS inStrUctionS refillinG the liQuid propane CYlinder 11 We recommend that you refill the LP cylinder before it is completely empty. Removal of the LP cylinder 2 A) Close cylinder valve (turn clockwise) (1). 1 B) Unscrew regulator coupling by turning counterclockwise, by hand only (2). C) Loosen cylinder lock wing nut and turn cylinder lock up out of the way. D) Lift cylinder off. To fill, take the LP cylinder to a gas propane dealer, or look up “gas-propane” in the phone bo
Inhaltszusammenfassung zur Seite Nr. 12
oPErating inStrUctionS snap iGnition operation m always open the lid before igniting the burners Each control knob has its own igniter electrode built in. To create a spark you must push the control knob in (a) and turn to “START/High” (b). This action will generate gas flow and a spark to the burner lighting tube (C). You will hear a “snap” from the igniter. You will also see a 3˝ - 5˝ orange flame coming from the burner lighting tube at the left side of the burner (d). Continue to hold the
Inhaltszusammenfassung zur Seite Nr. 13
oPErating inStrUctionS liGhtinG 13 Summary lighting instructions are inside the left hand cabinet door. 1 m danGer failure to open the lid while igniting the barbecue’s burners, or not waiting 5 minutes to allow the gas to clear if the 5 barbecue does not light, may result in an explosive flame-up which can cause serious bodily injury or death. main burner snap iGnition Note: Each control knob snap igniter creates a spark from the igniter electrode to the burner lighting tube. You generate t
Inhaltszusammenfassung zur Seite Nr. 14
oPErating inStrUctionS main burner manual liGhtinG m danGer 1 failure to open the lid while igniting the barbecue’s burners, or not waiting 5 minutes to allow the gas to clear if the barbecue does not light, may result in an explosive flame-up which can cause serious bodily injury or death. 6 A) Open the lid (1). B) Make sure all burner control knobs are turned off (2). (Push each knob in and turn clockwise to ensure they are in the “OFF” position.) m warninG: the burner control knobs must
Inhaltszusammenfassung zur Seite Nr. 15
oPErating inStrUctionS GrillinG methods 15 Note: If grill looses heat while cooking refer to the troubleshooting section of this manual. You can adjust the individual burners as desired. The control settings are start/hi, medium, low , or off. If burners go out during cooking, turn off all burners and wait 5 minutes before relighting. m warninG: Check the bottom tray and catch pan for grease build-up before each use. r emove excess grease to avoid a grease fire in the bottom tray. D C B A pr
Inhaltszusammenfassung zur Seite Nr. 16
oPErating inStrUctionS • Foods placed on the cooking grate directly above burners may require turning or GrillinG tips & helpful hints moving to a less hot area. • Always preheat the grill before cooking. Set all burners on “HI” heat and close lid; • Use tongs rather than a fork for turning and handling meats to avoid losing natural heat for 10 minutes, or until thermometer registers 500˚-550˚F (260˚-288˚C). juices. Use two spatulas for handling large whole fish. • Sear meats and cook
Inhaltszusammenfassung zur Seite Nr. 17
oPErating inStrUctionS manuallY liGhtinG the side burner 17 m danGer 6 failure to open the lid while igniting the side burner, or not 1 waiting 5 minutes to allow the gas to clear if the side burner does not light, may result in an explosive flare-up that can cause serious bodily injury or death. A) Open the side burner lid (1). 5 B) Check that the side burner valve is turned off (2) (Push control knob in and turn clockwise to ensure that it is in the “OFF” position), turn all burners not be
Inhaltszusammenfassung zur Seite Nr. 18
troUbLEShooting a operatinG the handle liGht ™ The Weber Grill Out Handle Light has a built-in “Tilt Sensor.” With the power button (a) activated, the light will come on when the grill lid is open. The light will turn off when the lid is closed. For daytime use, deactivate the sensor by pressing power button (a). hanDLE Light troUbLEShooting problem CheCK Cure ™ weber Grill out handle Are the batteries old? Replace batteries. light does not light. Are the batteries installed correctly? See ass
Inhaltszusammenfassung zur Seite Nr. 19
SiDEbUrnEr maintEnancE side burner maintenanCe 19 m warninG: all gas controls and supply valves should be in 3 the “off” position. Make sure black wire is connected between the igniter and electrode. Make sure white wire is connected between the igniter and grounding clip. Spark should be a white/blue color, not yellow. 1 A) Igniter Wire (1) 2 B) Ground wire (2) C) Burner (3) side burner Grate side burner cap side burner ring & head igniter electrode 1 2 Control Knob igniter troUbLEShooting p
Inhaltszusammenfassung zur Seite Nr. 20
maintEnancE ® weber spider/inseCt sCreens ® Your Weber gas barbecue, as well as any outdoor gas appliance, is a target for spiders and other insects. They can nest in the venturi section (1) of the burner tubes. This 1 blocks the normal gas flow, and can cause the gas to flow back out of the combustion air opening. This could result in a fire in and around the combustion air openings, under the control panel, causing serious damage to your barbecue. The burner tube combustion air opening is
