Inhaltszusammenfassung zur Seite Nr. 1
GS a GrILL
Natural Gas Grill Owner’s Guide
ESNA
Guía del Propietario de la Barbacoa de Gas Natural - Pg. 23
Mode d’emploi du grill à gaz naturel - Pg. 43
320
#89963
You Must read this owNer’s Guide m warNiNG: follow all leak-check
Before oPeratiNG Your Gas Grill.
procedures carefully in this manual prior
to barbecue operation. do this even if the
barbecue was dealer-assembled.
m daNGer
if you smell gas:
NotiCe to iNstaller: these instructions
1. shut off gas to the appliance.
must be left
Inhaltszusammenfassung zur Seite Nr. 2
WarNINGS m daNGer f ailure to follow the dangers, warnings and Cautions contained in this o wner’s Manual may result in serious bodily injury or death, or in a fire or an explosion causing damage to property. m warNiNGs m do not attempt to disconnect any gas fitting while your barbecue is in operation. m do not store a spare or disconnected liquid propane cylinder m use heat-resistant barbecue mitts or gloves when operating under or near this barbecue. barbecue. m improper assembly may be da
Inhaltszusammenfassung zur Seite Nr. 3
TabLE oF NTENTS co WNINGS ar .......................................... 2 INTEN ma aNcE ..................................... 18 CLEANING . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18 ® TabLE oF NTENTS co ................................. 3 WEBER SPIDER/INSECT SCREENS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18 BURNER TUBES CLEANING OR REPLACEMENT . . . . . . . . . . . . . . . . . . . . . . 19 ® EXPLoDED VI
Inhaltszusammenfassung zur Seite Nr. 4
EXPLoDED VIEW • DIa Grama DE DESPIE cE • VUE E cLa TEE Spirit_320_NG_US_061610 1 2 3 4 24 5 6 7 25 8 26 9 27 28 10 29 11 30 31 12 13 32 14 15 33 16 34 35 36 17 18 19 37 20 38 21 39 22 40 41 23 42 4
Inhaltszusammenfassung zur Seite Nr. 5
EXPLDED VIEW LIST o • LIST DEL DI a a G DE DESPIE rama E c • LISTE DE L VUE E a L c a TEE 1. shroud hardware 15. f ront f rame support 29. r ear Burner t ube Accesorios de la cubierta Soporte delantero del bastidor Tubo quemador posterior Kit d’assemblage de boîtier Panneau de cadre avant Tuyau de brûleur arrière 2. thermometer 16. left t rim Piece 30. Middle Burner t ube Termómetro Pieza de adorno izquierda Tubo quemador del medio Thermomètre Élément de décoration gauche Tuyau de brûleur centra
Inhaltszusammenfassung zur Seite Nr. 6
WarraNTY Weber-Stephen Products LLC (Weber) hereby warrants to the ORIGINAL PURCHASER of this Deterioration or damage due to severe weather conditions such as hail, hurricanes, earthquakes ® Weber gas grill that it will be free of defects in material and workmanship from the date of purchase or tornadoes, discoloration due to exposure to chemicals either directly or in the atmosphere, is not as follows: covered by this Limited Warranty . Aluminum castings: 25-years (2 years on paint; excludes
Inhaltszusammenfassung zur Seite Nr. 7
GaS INSTrUc TINS o iNstall G as suPPl Y General specifications f or Piping Note: Contact your local municipality for building codes regulating outdoor gas barbecue installations. In absence of Local Codes, you must conform to 7 the latest edition of the National Fuel Gas Code: ANSI Z 223.1/NFPA 54, or CAN/ CGA-B149.1, Natural Gas and Propane Installation Code. WE RECOMMEND THAT THIS INSTALLATION BE DONE BY A PROFESSIONAL. Some of the following are general requirements taken from the latest
Inhaltszusammenfassung zur Seite Nr. 8
GaS INSTrUc TIoNS tYPe of G as Your natural gas grill is factory built to operate using natural gas only . Never attempt to 1 operate your grill on gases other than the type specified on the grill rating plates . Y our g r ill oper at es at 7" of w at er column pr essur e . If r eplacement of the hose becomes necessary, factory specified parts are required . See your local dealer . ® For safety and design reasons, the conversion of a Weber grill from operation using Natural gas to operation
Inhaltszusammenfassung zur Seite Nr. 9
GS INST a U r c TINS o r emove Control Knobs & Control Panel f or leak t esting 1 2 You will need: Phillips screwdriver . A) Take off the burner control knobs (1) . B) Remove screw and washer from back of control panel with a Phillips screwdriver (2) . C) Remove machine screw from lower left and right side of control panel with a Phillips screwdriver (3) . 3 D) Tilt the back edge of the control panel up . Carefully lift control panel up and away from frame (4) . E) Disconnect the igniter wire
Inhaltszusammenfassung zur Seite Nr. 10
GaS INSTrUc TIoNS Check A) Hose to manifold connection (1) . 2 B) Side burner hose to manifold connection and side burner hose to side burner gas line connection (2) . C) Side burner hose to side burner connection, side burner valve to orifice (3) . m warNiNG: if there is a leak at connection (1), (2), (3), retighten the fitting with a wrench and recheck for leaks with soap and water solution. if a leak persists after retightening the fitting, turn off the gas. do Not oPerate the Grill. Con
Inhaltszusammenfassung zur Seite Nr. 11
bEF E USING THE G or ILL r slide-out Grease tra Y aNd disPosaBle driP P aN Your grill was built with a grease collection system . Check the slide-out grease tray and disposable drip pan for grease build-up each time you use your grill . Remove excess grease with a plastic spatula; see illustration . When necessary, wash the grease tray and drip pan with a soap and water solution, then rinse with clean water . Replace the disposable drip pan as needed . m warNiNG: Check the slide-out grease tr
Inhaltszusammenfassung zur Seite Nr. 12
maIN bUrNEr IGNITIoN & USa GE MaiN B urNer iGNitioN Summary lighting instructions are inside the left hand cabinet door . 2 2 OFF APAGADO ARRETE OFF APAGADO 5 ARRETE m daNGer 5 f ailure to open the lid while igniting the barbecue’s burners, 1 4 or not waiting 5 minutes to allow the gas to clear if the 1 4 barbecue does not light, may result in an explosive flare-up which can cause serious bodily injury or death. ® 1 Crossover ignition system Note: The Crossover® Ignition System ignites BURN
Inhaltszusammenfassung zur Seite Nr. 13
maIN U b NE r IGNITI r oN & USa GE MaiN B urNer MaNual iGNitioN 2 m daNGer OFF APAGADO ARRETE f ailure to open the lid while igniting the barbecue’s burners, or not waiting 5 minutes to allow the gas to clear if the barbecue does not light, may result in an explosive flare-up 5 1 which can cause serious bodily injury or death. 1 A) Open the lid (1) . B) Make sure all burner control knobs are turned OFF (2) . (Push each knob down and turn clockwise to ensure they are in the OFF position .) C
Inhaltszusammenfassung zur Seite Nr. 14
SIDE U b NE r IGNITI r N & US o a GE side B urNer iGNitioN the grill illustrated may Summary lighting instructions are inside the left hand cabinet door . have slight differences than the model purchased. m daNGer f ailure to open the lid while igniting the side burner, or not waiting five minutes to allow the gas to clear if the side burner does not light, may result in an explosive flare-up which can cause serious bodily injury or death. 2 1 m warNiNG: Check hose before each use of barbec
Inhaltszusammenfassung zur Seite Nr. 15
SIDE U b NE r IGNITI r oN & USa GE side B urNer MaNual iGNitioN the grill illustrated may have slight differences m daNGer than the model purchased. f ailure to open the lid while igniting the side burner, or not waiting five minutes to allow the gas to clear if the side burner does not light, may result in an explosive flare-up that can cause serious bodily injury or death. 2 A) Open the side burner lid (1) . B) Check that the side burner valve is turned off (2) (Push control knob in and t
Inhaltszusammenfassung zur Seite Nr. 16
GrILLING TIPS & HELPFUL HINTS • Al w a y s pr eheat the g r ill bef or e cooking . Set all b ur ner s on HI heat and close lid; heat for 10 minutes, or until thermometer registers 500°-550° F (260°-288°C) . • Sear meats and cook with the lid do wn f or perf ectl y g r illed f ood e v er y time . • Gr illing times in r ecipes ar e based on 70°F (20°C) w eather and lit tle or no wind. Allo w more cooking time on cold or windy days, or at higher altitudes . Allow less cooking time in
Inhaltszusammenfassung zur Seite Nr. 17
TU ro LESH b oo TING PLE rob m HE c K c SL o UTIoN Burners burn with a yellow or orange flame, in Inspect Spider/Insect screens for possible obstructions . Clean Spider/Insect screens . Refer to “ANNUAL conjunction with the smell of gas. (Blockage of holes .) MAINTENANCE” . Burner does not light, or flame is low in hi position. Is fuel hose bent or kinked? Straighten fuel hose . Burner does not ignite when you push the igniter Be sure that there is gas flow to the burners by If match lighting i
Inhaltszusammenfassung zur Seite Nr. 18
maINTENaNcE ® CleaNiNG weBer sPider/iNseCt sCreeNs ® ® Your Weber gas barbecue, as well as any outdoor gas appliance, is a target for spiders m warNiNG: t urn your w eber gas barbecue off and wait for it and other insects . They can nest in the venturi section (1) of the burner tubes . This to cool before cleaning. blocks the normal gas flow, and can cause the gas to flow back out of the combustion air ® m CautioN: do not clean your flavorizer bars or cooking opening . This could result in
Inhaltszusammenfassung zur Seite Nr. 19
maINTENaNE c BurNer tuBes CleaNiNG or rePla CeMeNt 1 2 You will need: Phillips screwdriver and flathead screwdriver . ® A) Your Weber gas barbecue must be OFF and cool . B) Turn gas OFF at source . ® C) Remove cookbox components - warming rack, grates and Flavorizer bars . 3 Control Panel r emoval To remove control panel: A) Take off the burner control knobs (1) . B) Remove screw and washer from back of control panel with a Phillips screwdriver (2) . C) Remove machine screw from lower left and r
Inhaltszusammenfassung zur Seite Nr. 20
maINTENaNcE ® eleCtroNiC Crosso Ver iGNitioN s YsteM oPeratioNs ® If the Electronic Crossover Ignition System fails to ignite the BURNER 1, light BURNER 1 with a match . If BURNER 1 lights with a match, then check the Electronic Ignition . • Chec k that both of the ignition wir es ar e at t ached at the ignit er module pr oper l y . • Chec k that the Electr onic Ignition b ut t on is w or king b y list ening and looking f or spar ks at BURNER 1 . r eplace Battery if Necessary AAA alkaline b
