Inhaltszusammenfassung zur Seite Nr. 1
R
R
E
E
B
B
E
E
W
W
Owners Guide
DANGER
If you smell gas:
1. Shut off gas to the appliance.
Liquid Propane Gas
2. Extinguish any open flames.
3. Open lid
4. If odor continues, keep away from the
appliance and immediately call your gas
supplier or your fire department.
Leaking gas may cause a fire or explosion
which can cause serious bodily injury or
death, or damage to property.
WARNING
1. Do not store spare liquid propane
cylinder within 10 feet (3m) of this
appliance.
2. Do not store or us
Inhaltszusammenfassung zur Seite Nr. 2
DANGER Failure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manual may result in serious bodily injury or death, or in a fire or an explosion causing damage to property. WARNINGS Do not store a spare or disconnected liquid propane cylinder under or near this barbecue. Improper assembly may be dangerous. Please carefully follow the assembly instructions in this manual. After a period of storage, and/or nonuse, the Weber Gas Barbecue should be checked for gas le
Inhaltszusammenfassung zur Seite Nr. 3
Warranty Weber-Stephen Products Co. (Weber) hereby warrants to the ORIGINAL PURCHASER of this Weber Gas Grill There are no other express warrants except as set forth that it will be free of defects in material and herein and any applicable implied warranties of workmanship from the date of purchase as follows: merchantability and fitness are limited in duration to the period of coverage of this express written Limited Aluminum Castings, lifetime, 1 year paint Warranty. Some regions do not allow
Inhaltszusammenfassung zur Seite Nr. 4
Contents Danger & Warnings ....................................................................... A-2 Warranty ........................................................................................ A-3 General Instructions ...................................................................... A-5 Exploded View ............................................................................... A-6 Parts List ....................................................................................... A-
Inhaltszusammenfassung zur Seite Nr. 5
Storage General Instructions • The gas must be turned OFF at the LP cylinder Your Weber Gas Barbecue is a portable outdoor when the Weber Gas Barbecue is not in use. cooking appliance. With the Weber Gas Barbecue you • When the Weber Gas Barbecue is stored indoors, can grill, barbecue, roast and bake with results that are the gas supply must be disconnected and the LP difficult to duplicate with indoor kitchen appliances. cylinder stored outdoors in a well-ventilated space. The closed lid and Fl
Inhaltszusammenfassung zur Seite Nr. 6
1 Genesis Gold-C LP 04/18/01 2 3 35 4 5 36 6 7 37 8 38 9 39 40 10 41 11 42 16 12 19 13 14 43 18 15 16 44 17 45 18 46 47 19 20 48 21 49 22 23 24 50 25 26 27 51 40 28 52 53 29 54 30 55 26 56 57 58 31 32 59 26 33 60 34 A-6
Inhaltszusammenfassung zur Seite Nr. 7
1. Hair Pin Cotter 35. Thermometer 2. Hinge Pin 36. Right Endcap 3. Left Endcap 37. Burner Control Knobs 4. Shroud 38. Control Panel 5. 1/4-20 x 1 1/4 inch Bolt 39. Igniter Button 6. Handle lock 40. Control Panel Hardware 7. Handle 41. Side burner ™ 8. Warm-Up Basket 42. Side burner bracket Right side 9. Warming Rack 43. Side burner support clip 10. Cooking Grates 44. Side burner bracket Left side ® 11. Flavorizer Bars 45. Crossover Tube 12. Cooking Box 46. Front and Back Burners 13. 1/4-20 keps
Inhaltszusammenfassung zur Seite Nr. 8
© 2001 Weber-Stephen Products Co., Weber, the silhouette, and the kettle configuration are registered trademarks ® of Weber-Stephen Products Co., 200 East Daniels Road, Palatine, IL, 60067-6266, U.S.A. This product is covered by one or more United States patents and patents in other nations globally. Printed in the U.S.A. A-8
Inhaltszusammenfassung zur Seite Nr. 9
Remove Packaging from Grill Remove Grill from Lower Packaging Remove all tape from packaging. Remove bottom rack from top of packaging. Remove outer box. Pull out WARNING: Lifting the barbecue from the lower bottom tray from cooking box. Remove packaging packaging requires at least two people. material from bottom tray, catch pan holder, catch pan, With two people: lift straight up and over lower and drip pan. packaging and cardboard support. A-9
Inhaltszusammenfassung zur Seite Nr. 10
You will need: 1/2 inch bolts (1/4 x 20 x 1/2 inch bolts) - 4 Phillips screwdriver 7/16 open-end or an adjustable wrench Nylon Washers - 4 Flavorizer Bars - 5 Left Work Surface - 1 Cooking Grates - 2 Right Work Surface and Side Burner - 1 Condiment basket - 1 Bottom Shelf - 1 LP Cylinder - 1 Slide Out Buttom Tray - 1 Catch pan holder - 1 Catch Pan - 1 Disposable Drip Pans - 2 A-10
Inhaltszusammenfassung zur Seite Nr. 11
Assembly Instructions Install the slide out bottom tray Slide the bottom tray onto the mounting rails under the You will need: the slide out bottom tray(1), catch pan cooking box with finger grip toward you(1). holder(2), catch pan and one disposable drip pan. WARNING: Do not line bottom tray with aluminum foil. It can cause grease fires by trapping the grease and not allowing grease to flow into the catch pan. (1) (2) Hook the ends of the catch pan holder into the hole in the slide out bottom
Inhaltszusammenfassung zur Seite Nr. 12
Install Flavorizer® Bars and Cooking Grates Installing the warming rack You will need: five Flavorizer Bars and two cooking You will need: warming rack. grates. Set the warming rack into the slots at the rear of the Place the Flavorizer Bars side by side in the cooking cooking box. box. Set the cooking grates onto the ledges in the cooking box with the rounded sides up. Install the bottom shelf You will need: Bottom shelf. Set the bottom shelf in place between the two frame connectors underneath
Inhaltszusammenfassung zur Seite Nr. 13
Installing Work Surfaces & Gas Connection Guidelines Install Left Work Surface Check that all burner valves are off You will need left work surface, two 1/2 inch bolts, two You will need: burner control knobs. nylon washers and a 7/16 inch or adjustable wrench. Valves are shipped in the OFF position, but you should Insert the left work surface tabs in the slots in the check to be sure that they are turned OFF. Put the frame(1). Slip washers on the bolts and insert the bolts knob on each valve. C
Inhaltszusammenfassung zur Seite Nr. 14
Fill liquid propane cylinder Important LP Cylinder Information Note - The liquid propane cylinder manufacturer is Failure to follow these DANGER statements exactly responsible for the materials, workmanship and may result in a fire causing death or serious injury. performance of the cylinder. If the cylinder has a DANGER defect, malfunctions, or you have a question regarding NEVER store a spare LP Cylinder under or near the cylinder, call the cylinder manufacturer’s customer this barbecue. ser
Inhaltszusammenfassung zur Seite Nr. 15
Hang filled liquid propane cylinder on fuel gauge Connect filled liquid propane cylinder Loosen the tank lock wing nut. Swing the cylinder lock WARNING: Make sure that the cylinder valve is up. Tighten the wing nut so that the cylinder lock is up closed. Close by turning clockwise. and to the side. Hook the liquid propane cylinder onto Remove plastic dust cover from the fuel cylinder valve. the fuel gauge. Loosen the tank lock wing nut. Swing Screw the regulator coupling onto the tank valve(1)
Inhaltszusammenfassung zur Seite Nr. 16
Connect side burner to manifold WARNING: Perform these leak checks even if WARNING: Make sure gas supply is off. your barbecue was dealer or store assembled. Connect the side burner hose as follows: You will need: a soap and water solution, and a rag or 1) Slide back the collar of the quick disconnect on the brush to apply it. manifold. Note - Since some leak test solutions, including soap 2) Push the male fitting of the side burner hose into and water, may be slightly corrosive, all connect
Inhaltszusammenfassung zur Seite Nr. 17
Reinstall control panel (after checking for gas WARNING: Do not ignite burners when leak leaks) checking. (1) Set the control panel in place over both sides of Check for leaks by wetting the connections with the the frame. Hold the crossover ignition button up soap and water solution and watching for bubbles. If while setting the control panel in place. bubbles form or if a bubble grows, there is a leak. Check: 1) Hose to manifold connection. WARNING: If there is a leak at connection (1),
Inhaltszusammenfassung zur Seite Nr. 18
Operating WARNING: The burner control knobs must be in Lighting the OFF position before turning on the liquid Summary lighting instructions are on the control panel. propane cylinder tank valve. If they are not in the OFF position, when you turn on the LP cylinder DANGER valve, the “excess gas flow control” feature will Failure to open the lid while igniting the activate, limiting the flow of gas from the LP barbecue’s burners, or not waiting 5 cylinder. If this should occur, turn OFF the LP
Inhaltszusammenfassung zur Seite Nr. 19
3) Turn the cylinder on by turning the cylinder valve Manual Lighting counterclockwise. 4) Strike a match and put the flame into the DANGER matchlight hole in the front of the cooking box. Failure to open the lid while igniting the WARNING: Do not lean over open barbecue. barbecue’s burners, or not waiting 5 minutes Keep your face and body at least one foot away from the matchlight hole when lighting the to allow the gas to clear if the barbecue does barbecue. not light, may result in an exp
Inhaltszusammenfassung zur Seite Nr. 20
Lighting the side burner if the main burners are lit. Lighting the Side Burner 1) Open the side burner lid. 2) Push down and turn the side burner control to HI. The side burner has a separate ignition system from 3) Press the side burner igniter button several times so the main cooking box. it clicks each time. CAUTION: Side burner flame may be difficult to DANGER see on a bright sunny day. Failure to open the lid while igniting the side 1 burner, or not waiting 5 minutes to allow the 2 gas
