Inhaltszusammenfassung zur Seite Nr. 1
USER’S MANUAL for
Models CF9030, CF9055/56 & CF9085/86
Gas Barbecue Grill
50000993 02/04 Rev.2 En
Inhaltszusammenfassung zur Seite Nr. 2
Warnings FOR YOUR SAFETY If you smell gas: ¥ Shut off gas to the appliance ¥ Extinguish any open flame ¥ Open lid ¥ If odor continues, immediately call your gas supplier or fire department. FOR YOUR SAFETY Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. An LP cylinder not connected for use shall not be stored in the vicinity of this or any other appliance. • Always read and understand the WARNINGS and SAFETY INSTRUCTIONS that ar
Inhaltszusammenfassung zur Seite Nr. 3
Warnings SIGNAL WORDS: The Signal Words used in this Manual, and their intended meanings, are as follows : DANGER: Indicates that a failure to observe the safety instructions could result in death or catastrophic bodily injury. WARNING: Indicates that a failure to observe the safety instructions could result in serious bodily injury. CAUTION: Indicates that a failure to observe the safety instructions could result in property damage or minor bodily injury. NOTE: Designates important informa
Inhaltszusammenfassung zur Seite Nr. 4
36” (1 m) Warnings A. SAFE LOCATIONS FOR USE OF THIS OUTDOOR GRILL DANGER: • Never use this outdoor Grill inside any building, garage, shed or breezeway, or inside any boat, trailer or recreational vehicle, to prevent a possible fire and to prevent the possibility of carbon monoxide poisoning or asphyxiation. WARNINGS: • Always confirm that this Grill is not positioned under a combustible object (e.g., an awning or umbrella) or in a covered area (e.g., a porch or gazebo) before lighting it, to
Inhaltszusammenfassung zur Seite Nr. 5
Warnings B. SAFE USE OF LP (PROPANE) GAS DANGER: • Never install a propane cylinder that is more than 80 % full, as the contents may lack adequate room for expansion when exposed to heat. Propane vapor may then be vented through the pressure release valve, which could accumulate in a pool and later result in a fire or explosion. Always instruct your certified propane fuel supplier to confirm by weight that your cylinder is not more than 80 % full. An empty cylinder will weigh about 18 lb., while
Inhaltszusammenfassung zur Seite Nr. 6
Safety • Always promptly shut off the gas supply and immediately extinguish all flames if you smell gas. Always seek assistance from your gas supplier or local Fire Department if the gas smell persists, because of the danger of fire or explosion. • Always confirm that there are no gas leaks before lighting this Grill. Apply a 50/50 solution of liquid soap and water to the gas supply line connectors with a brush or spray bottle, and watch for bubbles. Never use a match or open flame to test for g
Inhaltszusammenfassung zur Seite Nr. 7
Table of Contents Safety Important Warnings .................................................................. i - v Clearance Requirements................................................................ ii Table of Contents .......................................................................... 1 Fuels ............................................................................................. 2 Safety.........................................................................................
Inhaltszusammenfassung zur Seite Nr. 8
Safety FUELS WARNING: Never use Natural Gas in a Grill that has been configured to burn Propane Gas, and never use Propane Gas in a Grill that has been configured to use Natural Gas, to avoid possible bodily injury. Always consult the Rating Label on the back of your Grill to confirm which fuel must be used with the Grill. WARNING: Use only the pressure regulator and type I propane gas supply coupling and hose that is originally provided with this appliance or as specified, (see Fig. 2). ADDI
Inhaltszusammenfassung zur Seite Nr. 9
Safety DANGER: a) Do not store a spare LP - Gas Cylinder under or near this appliance b) Never fill the cylinder beyond 80% full; and c) If the information in a) and b) is not followed exactly, a fire causing death or serious injury may occur. WARNING: Always confirm that the openings in the cylinder compartment of the Grill are free of any obstructions that would restrict the circulation of ventilation air. Good ventilation will prevent any possible accumulation of leaked propane vapor, which
Inhaltszusammenfassung zur Seite Nr. 10
Gas Hookup Hooking Up to the LP (Propane) Gas Supply FOR YOUR SAFETY 1. WARNING: Never store or use gasoline or any other volatile substance in the vicinity of this Grill. 2. WARNING: Never store a spare propane cylinder in the vicinity of this Grill, or in the vicinity of any other potential heat source. LP (PROPANE) GAS SUPPLY CONNECTION 1. Always place the propane tank in the tank locator hole in the bottom pan of the cylinder compartment. 2. Always confirm that all burner control knobs a
Inhaltszusammenfassung zur Seite Nr. 11
Gas Hookup Natural Gas Supply Connection TO CONNECT: 1. Push back the Sleeve on the Socket as shown below Retract Sleeve (see Fig. 6a). 2. Insert Plug and release the Sleeve (see Fig. 6b). 3. Push the Plug until Sleeve snaps forward to lock the Fig. 6a Plug in the Socket. • WARNING: Always conduct the following safety tests before lighting the Grill, to prevent a possible fire or explosion (see leak test below). TO DISCONNECT: Release Sleeve Release Sleeve Fig. 6b 1. Push Sleeve back and pull t
Inhaltszusammenfassung zur Seite Nr. 12
Operation Control Functions PROPANE TANK VALVE WARNING: Never open the Tank Valve unless the Grill is being prepared for use, to prevent the pooling of propane vapor. Always open the Valve immediately before lighting the Grill, and always close it immediately after cooking has been completed. BURNER CONTROL VALVES On Model CF9030, three valves independently control gas flow to each burner, as indicated on the front Control Panel. On Model CF9055/56, four valves independently control gas flow to
Inhaltszusammenfassung zur Seite Nr. 13
Operation Lighting the Main Burners NOTE: When lighting the grill for the first time, burn 1. Always open the Hood completely and always inspect with the main burners on HIGH for at least 30 minutes, the Grill and burners to confirm that all components to burn off any manufacturing residues. are properly positioned before lighting the main burners. WARNING: Never stand with your head directly over the Grill when preparing to light the main burners, to prevent possible bodily injury. 2. Always
Inhaltszusammenfassung zur Seite Nr. 14
Operation Turning the Burners Off 1. Always turn the burner control knob(s) to the OFF position when cooking has been completed. 2. Promptly turn OFF the gas supply valve at the propane cylinder or at the main natural gas supply line. 3. Close the Hood of the Grill. FLARE-UPS “Flare-ups” sometimes occur when food drippings fall onto the hot sear plates or burners and ignite. Some flaring is normal and desirable, as it helps impart the unique flavors associated with grilled foods. Controlling the
Inhaltszusammenfassung zur Seite Nr. 15
Operation Lighting the Rotisserie Burner (Model CF9085/86) The Rotisserie burner provides the steady, even heat required to cook poultry and roasts to self-basted perfection. TO START THE ROTISSERIE BURNER: 1. Always open the Hood completely before attempting to light the Grill. • WARNING: Never stand with your head directly over the Grill when preparing to light the Rotisserie burner, to prevent possible bodily injury. 2. Always confirm that all of the burner control knobs are in the OFF posit
Inhaltszusammenfassung zur Seite Nr. 16
Operation Rotisserie Setup (Optional for Model CF9030 & CF9055/56) The Rotisserie burner is intended to be used for rotisserie cooking only. WARNING: Never use the main burners while using the Rotisserie burner, as that could result in igniting the drippings, or overheating your Grill. The Rotisserie assembly includes a Rotisserie counterweight for large or irregular forks food items ; using the counterweight will reduce the strain on the motor. Bushing 1. Remove the warming rack. Lay a flat Ro
Inhaltszusammenfassung zur Seite Nr. 17
Operation Lighting the Side Burner (Optional to all models except CF9055/86) WARNING: Never stand with your head directly over the Grill when preparing to light the side burner, to prevent possible bodily injury. 1. Turn the side burner control knob to HI (see Fig. 13). 2. Turn the Igniter Knob clockwise until the burner ignites. The burner should light within four clicks of the igniter. NOTE: Observe the flame pattern. Soft blue flames are normal ; hard blue flames or wavy yellow flames are n
Inhaltszusammenfassung zur Seite Nr. 18
Operation Using the Smoker Box (Model CF9085/86) The CF9085/86 model Grill is equipped with a Rotisserie Burner Smoker Box. You can add a distinct, smoky flavor to your food by burning a variety of woods or herbs in this unit. 1. Always soak any wood chips or herbs that you wish to smoke for a half-hour or more. 2. Always pre-warm the Grill before adding your smoking agent to the Smoker Box. 3. Remove the lid from the Smoker Box with a pair of tongs, or while wearing an insulated protective mitt
Inhaltszusammenfassung zur Seite Nr. 19
Cooking Methods of Cooking With its combination of burners and accessories your gas grill can provide for virtually every conceivable style of cooking. • The powerful Main burners deliver the middle and high range of temperatures desired for traditional barbecuing. This includes searing and finishing steaks, hamburgers, pork chops and the like, or grilling chicken parts, sausages, or kebabs with more moderate heat (see Fig. 15a). • The Rotisserie burner, standard on Model CF9085/86, delivers the
Inhaltszusammenfassung zur Seite Nr. 20
Cooking One of the keys to extending your range of grilling capabilities is a fundamental understanding of the two common methods of cooking, Direct and Indirect cooking. In the Direct cooking method, food is placed directly above the heat source. This method is used in searing for example where you require high and immediate heat to quickly brown the outside layer of meats thereby sealing in their juices to enhance flavor. On the grill this is accomplished using one or both of your main burner
