ملخص المحتوى في الصفحة رقم 1
INSTALLATION &
OPERATION MANUAL
VCH SERIES
OVENS
MODELS:
VCH5 ML-126365
VCH8 ML-126366
VCH16 ML-126367
VCH88 ML-126368
VRT SERIES
OVENS
MODELS:
VRT32I ML-138024
For additional information on Vulcan-Hart or to locate an authorized parts
and service provider in your area, visit our website at www.vulcanhart.com
VULCAN-HART 3600 NORTH POINT BLVD.
DIVISION O
ملخص المحتوى في الصفحة رقم 2
VCH & VRT SERIES OVENS F-38055 (11-09) IMPORTANT FOR YOUR SAFETY THIS MANUAL HAS BEEN PREPARED FOR PERSONNEL QUALIFIED TO INSTALL ELECTRICAL EQUIPMENT, WHO SHOULD PERFORM THE INITIAL FIELD START- UP AND ADJUSTMENTS OF THE EQUIPMENT COVERED BY THIS MANUAL. FOR YOUR SAFETY DO NOT STORE OR USE GASOLINE OR OTHER FLAMMABLE VAPORS OR LIQUIDS IN THE VICINITYOF THIS OR ANY OTHER APPLIANCE. WARNING IMPROPER INSTALLATION, ADJUSTMENT, ALTERATION, SERVICE, OR MAINTE
ملخص المحتوى في الصفحة رقم 3
VCH & VRT SERIES OVENS F-38055 (11-09) TABLE OF CONTENTS IMPORTANT FOR YOUR SAFETY . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 GENERAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 INTRODUCTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
ملخص المحتوى في الصفحة رقم 4
VCH & VRT SERIES OVENS F-38055 (11-09) GENERAL shipment. Immediately after unpacking, INTRODUCTION check for possible shipping damage to the oven. Vulcan-Hart Ovens are produced with quality workmanship and material. If the oven is found to be damaged, Proper installation, usage, and save the packaging material and maintenance of your oven will result in contact the carrier within 15 days of many years of satisfactory performance. delivery. This manual is provided
ملخص المحتوى في الصفحة رقم 5
VCH & VRT SERIES OVENS F-38055 (11-09) diagrams and Specification Chart in the ELECTRICAL REQUIREMENTS back of this manual. ELECTRICAL CODES & STANDARDS: The cord and plug supplied is a suitable durable cord with a proper strain relief. The oven must be installed in accordance with: WARNING: All 110/120 volt ovens are equipped with a three-prong plug. It In the United States of America: is imperative that this plug must be 1. State and Local Codes. connected into a
ملخص المحتوى في الصفحة رقم 6
VCH & VRT SERIES OVENS F-38055 (11-09) OPERATION Cooking Time Knobs: CONTROLS Cooking time knobs set the desired cooking time. POWER HOLDING COOKING ON / OFF TEMPERATURE TEMPERATURE Hours knob: 0 to 99 SWITCH & KNOB - LIGHT KNOB - LIGHT Minutes knob: 0 to 99 LIGHT Seconds knob: 0 to 99 Start Button: Start Button engages the cooking thermostat after Cooking Timer has
ملخص المحتوى في الصفحة رقم 7
VCH & VRT SERIES OVENS F-38055 (11-09) 5. Check that the Oven Circulating OPERATING INSTRUCTIONS Fan(s) are running. 1. Turn On/Off Switch to ON 6. Check that the Holding position. On/Off indicator Light Temperature Indicator Light is and Holding Temperature Light illuminated. will illuminate. NOTE: 2. Turn Holding Temperature knob Each Oven is equipped with cooling to desired holding temperature. fans. The cooling fans may not operate when the oven is first
ملخص المحتوى في الصفحة رقم 8
VCH & VRT SERIES OVENS F-38055 (11-09) 3. Turn On/Off Switch to OFF 3. Remove the Interior Side Racks position. 4. Take the Interior Side Racks to a sink or dishwasher for a thorough EXTENDED SHUTDOWN cleaning. Use a mild soap and water solution to clean these Perform the following procedure to shut items. down the oven for an extended period of time. 5. If necessary, clean the interior of the oven with a damp cloth. 1. Perform the SHUTDOWN Wipe dry with a sof
ملخص المحتوى في الصفحة رقم 9
VCH & VRT SERIES OVENS F-38055 (11-09) 1. Never use any metal tools, the protective film to thicken. This is scrapers, files, wire brushes, unsightly, but is not a sign of permanent or scouring pads (except for damage. stainless steel scouring pads,) which will mar the surface. To remove heat tint, follow the routine cleaning procedure. Stubborn heat tint 2. Never use steel wool – which will require heavy-duty cleaning. To will leave behind particles that will reduce heat tin
ملخص المحتوى في الصفحة رقم 10
VCH & VRT SERIES OVENS F-38055 (11-09) LOCKOUT / TAGOUT PROCEDURE WARNING Always perform the LOCKOUT / TAGOUT PROCEDURE of your facility before removing any sheet metal panels or attempting to service this equipment. FAILURE TO COMPLY WITH THIS PROCEDURE CAN CAUSE PROPERTY DAMAGE, INJURY OR DEATH. The Lockout / Tagout Procedure is used to protect personnel working on an electrical appliance. Before performing any type of maintenance or service on an electrically operated
ملخص المحتوى في الصفحة رقم 11
VCH & VRT SERIES OVENS F-38055 (11-09) TROUBLESHOOTING SYMPTOMS POSSIBLE CAUSES REMEDY Oven not connected to Connect oven to power power source source ON/OFF switch not Press Power ON/OFF switch Oven not operating ON to ON Check circuit breaker No power Check GFCI Moisture problem Dry moisture problem Contact Authorized Service GFCI or Ground Fault Circuit Shorted element Provider Indicator tripped Contact Authorized Service Pinched/damaged wire Provider Contact Authorized Service
ملخص المحتوى في الصفحة رقم 12
VCH & VRT SERIES OVENS F-38055 (11-09) SPECIFICATIONS MODEL PAN PAN NEMA SHIP NO. QTY. SIZE HEIGHT DEPTH WIDTH WEIGHT VOLTS WATTS AMPS PLUG VCH8 8 ea. 18" x 26" 44.5" 37.25" 26.25" 334 lbs. 120 2160 18.0 5-15 12"x20" 16 ea. x 1 1/2" 1130mm 947mm 667mm 152 kg. 208 3800 9.6 6-30 240 5060 11.0 6-30 VCH16 12"x20" x 1 1/2" 208 5700 28.0 6-50 16 ea. 72.75" 37.25" 26.25" 480 lbs. 18" x 26" 240 7590 32.0 6-50 32 ea. 1848mm 947 mm 667 mm 218 kg. VCH5 18" x 26" 120 1320 1
ملخص المحتوى في الصفحة رقم 13
VCH & VRT SERIES OVENS F-38055 (11-09) WIRING DIAGRAMS VCH8 & VCH88 (208 V) Page 12
ملخص المحتوى في الصفحة رقم 14
VCH & VRT SERIES OVENS F-38055 (11-09) VCH8 (120 V) Page 13
ملخص المحتوى في الصفحة رقم 15
VCH & VRT SERIES OVENS F-38055 (11-09) VCH16 (208 V) Page 14
ملخص المحتوى في الصفحة رقم 16
VCH & VRT SERIES OVENS F-38055 (11-09) VCH16 (208 V – 3 PH) Page 15
ملخص المحتوى في الصفحة رقم 17
VCH & VRT SERIES OVENS F-38055 (11-09) VCH5 (120 V) Page 16
ملخص المحتوى في الصفحة رقم 18
VCH & VRT SERIES OVENS F-38055 (11-09) VCH5 (208 V) Page 17
ملخص المحتوى في الصفحة رقم 19
VCH & VRT SERIES OVENS F-38055 (11-09) VRT32I (208 V) Page 18
