ملخص المحتوى في الصفحة رقم 1
IMPORTANT FOR FUTURE REFERENCE
Please complete this information and retain this
manual for the life of the equipment:
Model #: ___________________________
Serial #: ___________________________
Date Purchased: ____________________
OPERATOR’S MANUAL
Marathoner Gold & SilverStar
GAS CONVECTION OVENS
SilverStar Models Marathoner Gold Models
SLGB/12CCH SLGS/12CCH GB/12CCH GB/22CCH GS/12CCH GS/22CCH
SLGB/12SC SLGS/12SC GB/12PC GB/22PC GS/12PC GS/22PC
SLGB/15CCH SLGS/15CCH GB/12RT GB/
ملخص المحتوى في الصفحة رقم 2
MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS SAFETY PRECAUTIONS Before installing and operating this equipment, be sure everyone involved in its operation is fully trained and aware of precautions. Accidents and problems can be caused by failure to follow fundamental rules and precautions. The following symbols, found throughout this manual, alert you to potentially dangerous conditions to the operator, service personnel, or to the equipment. This symbol warns of immediate hazards
ملخص المحتوى في الصفحة رقم 3
MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS TABLE OF CONTENTS Congratulations! You have purchased one of the finest pieces of heavy-duty commercial cooking equipment on the market. You will find that your new equipment, like all Southbend equipment, has been designed and manufactured to meet the toughest standards in the industry. Each piece of Southbend equipment is carefully engineered and designs are verified through laboratory tests and field installations. With proper care and fi
ملخص المحتوى في الصفحة رقم 4
SPECIFICATIONS MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS SPECIFICATIONS NOTICE Local codes regarding installation vary greatly from one area to another. The National Fire Protection Association, Inc. states in its NFPA 96 latest edition that local codes are the “authority having jurisdiction” when it comes to installation requirements for equipment. Therefore, installations should comply with all local codes. Southbend reserves the right to change specifications and product desig
ملخص المحتوى في الصفحة رقم 5
SPECIFICATIONS MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS SPECIFICATIONS GAS SUPPLY The serial plate is located inside the lower front panel. It indicates the type of gas the unit is equipped to burn. All Southbend equipment is adjusted at the factory. Check type of gas on serial plate. These models are design-certified for operation on natural or propane gases. For natural gas, the regulator is set to deliver a 4.5" W.C. pressure to the manifold. For propane gas, it is set to deliv
ملخص المحتوى في الصفحة رقم 6
SPECIFICATIONS MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS EXTERIOR DIMENSIONS Single-Deck Ovens Model Depth Dimensions Oven Interior Rack Clearance Shipping Crate Number A B C width depth height width depth width depth height volume weight GS/1… 38.5" 30" 34.375" 29" 22.5" 20" 28.25" 22" 55" 45.5" 45" 65.17 cu. ft. 620 lbs. SLGS/1… GB1… 45" 36.375" 40.75" 29" 28" 20" 28.25" 27.25" 55" 45.5" 45" 65.17 cu. ft. 690 lbs. SLGB/1… PAGE 6 OPERATOR’S MANUAL 1181887 REV 3 SPECIFICA
ملخص المحتوى في الصفحة رقم 7
SPECIFICATIONS MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS SPECIFICATIONS Double-Deck Ovens A B 8" 2.5" 18.625" 4" 38" 13.5" 2.5" 1.25" C TOP VIEW 29" 66.5" 64" 38.25" 29" 42" 22.875" 13" 9.5" 6" SIDE VIEW FRONT VIEW Model Depth Dimensions Oven Interior Rack Clearance Shipping Crate Number weight A B C width depth height width depth width depth height volume GS/2… 1040 lbs. 38.75" 30" 34.375" 29" 22.5" 20" 28.25" 22" 55" 45.5" 81.5" 118 cu. ft. SLGS/2… GS/2… 1080 lbs. 45.12
ملخص المحتوى في الصفحة رقم 8
SPECIFICATIONS MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS MINIMUM CLEARANCES ! WARNING There must be adequate clearance between the left side of the ovens and combustible construction. Minimum Clearance from Minimum Clearance from Combustible Construction Non-Combustible Construction Back 0" 0" Right Side 0" 0" Left Side 2" 0" Floor 0" 0" Adequate clearance must be provided in the aisle to allow the doors to open sufficiently to permit the removal of the racks and for serv
ملخص المحتوى في الصفحة رقم 9
INSTALLATION MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS INSTALLATION INSTALLATION NOTICE These installation procedures must be followed by qualified personnel or warranty will be void. Local codes regarding installation vary greatly from one area to another. The National Fire Protection Association, Inc. states in its NFPA 96 latest edition that local codes are the “authority having jurisdiction” when it comes to installation requirements for equipment. Therefore, installations sho
ملخص المحتوى في الصفحة رقم 10
INSTALLATION MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS Step 2a: Installation of Legs on Single-Deck Ovens 1. Raise oven sufficiently to allow clearance for the legs to be attached. Use of a lift truck or other mechanical lifting means is recommended. For safety, “shore up” and support the oven with an adequate blocking arrangement strong enough to support the load. (If it is absolutely necessary to rest the oven on its side, rest it on its left side or back side. Take care to prote
ملخص المحتوى في الصفحة رقم 11
INSTALLATION MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS INSTALLATION Step 2b: Installation of Legs on Double-Deck Ovens Double-deck oven can be shipped either already bolted together, or as two separate ovens to be bolted together after delivery. In either case, the oven that is (or will be) the lower oven will have leg pads already bolted to the bottom corners of the oven. Do the following: 1. Raise oven sufficiently to allow clearance for the legs to be attached. Use of a lift tru
ملخص المحتوى في الصفحة رقم 12
INSTALLATION MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS Step 3: Installation of Restraint (Only for Ovens with Casters) NOTICE For an appliance equipped with casters, (1) the installation shall be made with a connector that complies with the Standard for Connectors for Movable Gas Appliances, ANSI Z21.69 or Connectors for Moveable Gas Appliances, CAN/CGA-6.16, and a quick-disconnect device that complies with the Standard for Quick-Disconnect Devices for Use With Gas Fuel, ANSI Z21.
ملخص المحتوى في الصفحة رقم 13
INSTALLATION MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS INSTALLATION 2. Install eye-bolt (item “F”) to a frame member on the rear of the equipment. After checking carefully behind the frame member for adequate clearance, drill a 1/4" hole through the frame member. 3. Thread hex nut (item “G”) and slide the washer (item “H”) onto the eye-bolt. Insert the eye-bolt through the 1/4" drilled hole and secure with a washer (item “H”) and nylon lock nut (item “I”). 4. Using the spring-loade
ملخص المحتوى في الصفحة رقم 14
INSTALLATION MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS 5. Lift the top oven and position it on top of the lower oven, as shown in the drawing below. 6. Move to the rear of the ovens and remove the six screws shown as items “A” in the left-hand drawing below. Position the tie bracket (item “B”) as shown in the right-hand drawing below. Re-insert the screws that you just removed through the holes in the tie bracket, but do not tighten them yet. A B A PAGE 14 OPERATOR’S MANUAL
ملخص المحتوى في الصفحة رقم 15
INSTALLATION MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS INSTALLATION 7. Insert two bolts (items “A” in the following diagram) up through the top of the lower oven and screw them into the threaded holes in the bottom of the top oven. Tighten these bolts and the screws that you did not tightened in the previous step. A A 8. Assemble the gas piping shown in the following drawing. Be sure to check all connections for leaks once the oven has been installed. 3/4" Elbow 3/4" x 13-1/4"
ملخص المحتوى في الصفحة رقم 16
INSTALLATION MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS 9. Install the flue stack as shown in the following diagram: Flue Stack 10. Replace the right side insulation, exterior panel, and lower front panel that you removed in step 4 of this procedure. PAGE 16 OPERATOR’S MANUAL 1181887 REV 3 INSTALLATION
ملخص المحتوى في الصفحة رقم 17
INSTALLATION MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS INSTALLATION Step 5: Install Down Draft Diverter (if applicable) NOTICE Installation must use approved CSA International down draft diverter supplied by Southbend. If the oven flue is to be connected directly to an external vent, a down draft diverter must be installed. The installation of ventilation pipes through walls and roofs must conform to all local codes. To install the down draft diverter, do the following: 1. Sl
ملخص المحتوى في الصفحة رقم 18
INSTALLATION MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS Step 6: Installation of Optional Open Rack Storage An option for single-deck Marathoner Gold ovens is to have open rack storage below the oven. The following describes how to assemble this option. All holes are pre-drilled for the screws provided. 1. Attach the legs to the oven as described in installation Step 2b on page 11. 2. Attach the two frame hangers (items “A” in the following drawing). The flanged side of each rack ha
ملخص المحتوى في الصفحة رقم 19
INSTALLATION MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS INSTALLATION 4. Attach either the shelf or the two channel frames (depending on which option was ordered) as shown in the drawing below. Use the screws and four side rack clips provided to secure the shelf or channel frames to the rack guides. 5. Attach the rack stop using two screws. Attach the top of the rack stop to the rear frame hanger, and the bottom of the rack stop to the bottom shelf or the rear channel frame, as s
ملخص المحتوى في الصفحة رقم 20
INSTALLATION MARATHONER GOLD & SILVERSTAR GAS CONVECTION OVENS Step 7: Connect Electricity ! WARNING ELECTRIC GROUNDING INSTRUCTIONS This appliance (120V ovens only) is equipped with a three-prong (grounding) plug for your protection against shock hazard and should be plugged directly into a properly grounded three-prong receptacle. Do not cut or remove the grounding prong from this plug. NOTICE This appliance, when installed, must be electrically grounded in accordance with loca
