ملخص المحتوى في الصفحة رقم 1
MODEL
E X 1 3 D / E X 1 7 D
E X 2 1 D / E X 2 7 D
ISSUE EMD-EU1622
2ZZ9990063
Y
ملخص المحتوى في الصفحة رقم 2
ملخص المحتوى في الصفحة رقم 3
WARNING The engine exhaust from this product contains chemicals known to the State of California to cause cancer, birth defects or other reproductive harm. NOTICE US FEDERAL EMISSION COMPONENT DEFECT WARRANTY and CALIFORNIA EMISSION CONTROL WARRANTY are applicable to only those engines complied with EPA (Environmental Protection Agency) and CARB (California Air Resources Board) emission regulations. AIR INDEX An Air Index Information hang tag was supplied to this engine in accordance with the e
ملخص المحتوى في الصفحة رقم 4
FEDERAL EMISSIONS COMPONENT DEFECT WARRANTY EMISSIONS COMPONENT DEFECT WARRANTY COVERAGE This emission warranty is applicable in all States, except the State of California. Fuji Heavy Industries Ltd. and Robin America Inc., Wood Dale Illinois, (herein “ROBIN AMERICA”) warrant(s) to the initial retail purchaser and each subsequent owner, that this Nonroad engine (herein “engine”) has been designed, built, and equipped to conform at the time of initial sale to all applicable regulations of the U.S
ملخص المحتوى في الصفحة رقم 5
CALIFORNIA EMISSION CONTROL WARRANTY STATEMENT YOUR WARRANTY RIGHTS AND OBLIGATIONS The California Air Resources Board and Fuji Heavy Industries Ltd. (herein “FUJI”) are pleased to explain the emission control system warranty on your 2002 and later Small Off-Road engine (herein "engine"). In California, the engine must be designed, built and equipped to meet the State's stringent anti-smog standards. FUJI must warrant the emission control system on your engine for the periods of time described b
ملخص المحتوى في الصفحة رقم 6
When warranty repair is needed, the engine must be brought to an H. PARTS COVERED UNDER THE CALIFORNIA EMISSIONS authorized service dealer or warranty station’s place of business during WARRANTY normal business hours. In all cases, a reasonable time, not to exceed (1) Fuel Metering System 30 days, must be allowed for the warranty repair to be completed after (i) Carburetor and internal parts (and/or pressure regulator or the engine is received by the authorized service dealer or warranty station
ملخص المحتوى في الصفحة رقم 7
FOREWORD Thank you very much for purchasing a ROBIN ENGINE. Your ROBIN ENGINE can supply the power to operate various sorts of machines and equipment. Please take a moment to familiarize yourself with the proper operation and maintenance procedures in order to maximize the safe and efficient use of this product. Keep this owner’s manual at hand, so that you can refer to it at any time. Due to constant efforts to improve our products, certain procedures and specifications are subject to change wi
ملخص المحتوى في الصفحة رقم 8
1. SAFETY PRECAUTIONS Please make sure you review each precaution carefully. Pay special attention to statement preceded by the following words. “WARNING” indicates a strong possibility of severe personal injury or loss of life if WARNING instructions are not followed. “CAUTION” indicates a possibility of personal injury or equipment damage if instructions CAUTION are not followed. WARNING : EXHAUST PRECAUTIONS Never inhale exhaust gasses. They contain carbon monoxide, a colorless, odorless and
ملخص المحتوى في الصفحة رقم 9
Do not touch the spark plug and ignition cable when starting and operating the engine. Never make adjustments on the machinery while it is connected to the engine, without first removing the ignition cable from the spark plug. Turning the crankshaft by hand during adjusting or cleaning might start the engine, and cause serious injury to the operator. Operate the engine on a stable, level surface. If the engine is tilted, fuel spillage may result. NOTE Operating the engine at a steep incline may
ملخص المحتوى في الصفحة رقم 10
SYMBOLS Read the owner's manual. Stay clear of the hot surface. Exhaust gas is poisonous. Do not operate in an unventilated area. Stop the engine before refueling. US Fire, open flame and smoking prohibited. On (Run) Plus ; Positive polarity Off (Stop) Battery Engine oil Engine start (Electric start) Add oil 2. COMPONENTS (See Fig. 1 1 1 1 1) NOTE Please refer to the illustrations on the back page of the front cover or back cover for Fig. 1 1 1 1 1 to ! ! ! ! !000 indicated in the sentence. 00
ملخص المحتوى في الصفحة رقم 11
3. PRE-OPERATION CHECKS 4. ELECTRIC STARTER MODELS For electric starter operation, proper electric wiring NOTE arrangements are needed before normal engine operation. Engine shipped from our factory is without oil. Before starting engine, fill with oil. Do not over-fill. 1. BATTERY Use a battery rated 12V 24AH or larger. 1. CHECK ENGINE OIL (See Fig. 2 2 2 2 2) WARNING Before checking or refilling engine oil, be sure the engine is Battery electrolyte contains sulphuric acid. Protect located on
ملخص المحتوى في الصفحة رقم 12
5. OPERATING YOUR ENGINE 4. WIRING (See Fig. 4 4 4) 4 4 MAGNETIC SWITCH 1. STARTING CABLE (1) Open the fuel cock. (See Fig.4 q) To KEY SWITCH (TERMINAL "ST") (2) Turn the STOP SWITCH to the position “ I ” (ON). (See Fig.4 w) (3) Set the speed control lever 1/3 of the way towards the high EARTH WIRE speed position. (See Fig.4 e) (4) Close the choke lever. (See Fig.4 r) If the engine is cold or the ambient temperature is low, BATTERY close the choke lever fully. If the engine is warm or the a
ملخص المحتوى في الصفحة رقم 13
(3) Close the fuel cock. (See Fig.6 e) 2. PERIODIC INSPECTION (4) Pull the starter handle slowly and return the handle to its Periodic maintenance is vital to the safe and efficient operation original position when resistance is felt. This operation of your engine. is necessary to prevent outside moist air from intruding Check the table below for periodic maintenance intervals. into the combustion chamber. (See Fig.6 r) IT IS ALSO NECESSARY FOR THE USER OF THIS ENGINE STOPPING ENGINE WITH TH
ملخص المحتوى في الصفحة رقم 14
3. INSPECTING THE SPARK PLUG 6. CLEANING AIR CLEANER (See Fig.7 7 7 7 7-w w w w w) (See Fig.7 7 7 7 7-y y y y y,u u u u u) (1) Clean off carbon deposits on the spark plug electrode A dirty air cleaner element will cause starting difficulty, power using a plug cleaner or wire brush. loss, engine malfunctions, and shorten engine life extremely. Always keep the air cleaner element clean. (2) Check electrode gap. The gap should be 0.6 mm to 0.7 mm (0.02 inch.-0.03 inch.). Adjust the gap, if necessa
ملخص المحتوى في الصفحة رقم 15
7. PREPATIONS FOR STORAGE 9. EASY TROUBLESHOOTING (See Fig. ! ! ! ! !00)000 1. DISCHARGE FUEL (See Fig.8 8 8 8 8-q q q q q) WHEN ENGINE WILL NOT START : WARNING Flame Prohibited Perform the following checks before you take the engine to your Robin dealer. If you still have trouble after completing If you do not use the engine more than 1 month, discharge the checks, take the engine to your nearest Robin dealer. fuel to prevent gum in the fuel system and carburetor parts. Remove the fuel cup, pl
ملخص المحتوى في الصفحة رقم 16
10. SPECIFICATIONS MODEL EX13D EX17D EX21D EX27D Type Air-cooled, 4-cycle single cylinder, overhead camshaft, gasoline engine Displacement mL (cc) 126 169 211 265 kW/rpm 2.2/3600 2.9/3600 3.7/3600 5.1/3600 Continuous Output (HP/rpm) (3.0/3600) (4.0/3600) (5.0/3600) (7.0/3600) kW/rpm 3.2/4000 4.2/4000 5.1/4000 6.6/4000 Maximum Output (HP/rpm) (4.3/4000) (5.7/4000) (7.0/4000) (9.0/4000) Direction of Rotation Counterclockwise, as Viewed from P.T.O. Shaft side Lubricant Automotive detergent oil (API
ملخص المحتوى في الصفحة رقم 17
ملخص المحتوى في الصفحة رقم 18
MODEL E X 1 3 D / E X 1 7 D E X 2 1 D / E X 2 7 D ISSUE EMD-EU1622 2ZZ9990063 Y
