ملخص المحتوى في الصفحة رقم 1
Users Manual
®
MIRACLEAN ELECTRIC GRIDDLE
SERIES 2000
READ AND SAVE THIS MANUAL FOR FUTURE REFERENCE.
RECORD THE MODEL AND SERIAL SERIAL NO. ______________________________
®
NUMBERS OF THIS MIRACLEAN ELECTRIC
MODEL NO. _____________________________
GRIDDLE IN THE SPACES PROVIDED.
KEEP THESE NUMBERS FOR FUTURE REFERENCE.
IMPORTANT: Keep a copy of your bill of sale. The date on the bill establishes the warranty period should
service be required. If service is performed, it is in your interest to
ملخص المحتوى في الصفحة رقم 2
POST THIS LABEL IN A PROMINENT LOCATION ON YOUR UNIT. WARNING DO NOT STORE OR USE GASOLINE OR OTHER FLAMMABLE VAPORS OR LIQUIDS IN THE VICINITY OF THIS OR ANY OTHER APPLIANCE. Do not store flammable liquids near this or any other appliance. WARNING IMPROPER INSTALLATION, Gas Burns Shock ADJUSTMENT, ALTERATION, SERVICE OR MAINTENANCE CAN CAUSE PROPERTY DAMAGE, INJURY OR DEATH. READ THE INSTALLATION, OPERATING AND MAINTENANCE INSTRUCTIONS Improper installation THOROUGHLY BEFORE INSTALLING can c
ملخص المحتوى في الصفحة رقم 3
INTRODUCTION SAFETY PRECAUTIONS GENERAL ® Keating MIRACLEAN Electric Griddles are designed THIS SYMBOL WARNS YOU THAT SERIOUS BURNS to give maximum production efficiency, delivering high OR OTHER INJURIES MAY RESULT IF SAFETY INSTRUCTIONS ARE NOT FOLLOWED. quality food products. The following design features are ® incorporated into Keating MIRACLEAN Electric Griddles. This service manual should be retained in a safe place for future reference. The installation of your new griddle must confor
ملخص المحتوى في الصفحة رقم 4
LEVELING II INSTALLATION ® Your MIRACLEAN Griddle will operate at its highest efficiency when properly leveled. Place a level on the griddle plate from side to side. For griddles on legs, the This unit must be installed, inspected, calibrated and bottom foot of the leg is adjustable. Turn clockwise to serviced by qualified and/or certified and licensed decrease height or counterclockwise to increase height service personnel - you may void your Keating until level. For griddles on stands with cas
ملخص المحتوى في الصفحة رقم 5
pages 11 - 12 Wiring Diagram) to see if the griddle is *For runs greater than 75' up to 125', use the next wire connected three phase or single phase. All wires, size larger to keep the voltage drop to less than 3%. cords, plugs, receptacles and circuit breakers must be For runs greater than 125', consult the National sized adequately for the full load rating of the griddle as Electrical Code Handbook to help determine the proper specified by local codes or, in the absence of local wire size. co
ملخص المحتوى في الصفحة رقم 6
Figure 3-2 RECOMMENDED COOKING TEMPERATURES Top view placement of elements under MIRACLEAN plate. PRODUCT °F Eggs 250°F Bacon 325°F Sausage (patty or link) 325°F Hash Browns 350°F French Toast 350°F Wheat Cakes 360°F Hamburgers – 2/lb. (8oz.) 325°F 4/lb. (4 oz) 315°F 10/lb. (1.6oz) 310°F 5. After each load, scrape the griddle surface Grilled Cheese 325°F completely clean using the 4” wide replaceable Chicken Breasts (skinless) 350°F blade scraper. Hot Dogs – 45g each 310°F 57g each 310°F Salmon
ملخص المحتوى في الصفحة رقم 7
NEVER USE ICE TO COOL THE MIRACLEAN® CLEANING THE SURFACE. USE OF ICE MAY WARP THE GRIDDLE MIRACLEAN® SURFACE. ® The surface of the MIRACLEAN Griddle is very USE ONLY KEATING SUPPLIED CLEANING durable and with proper care, following the procedures TOOLS AND KLENZER. below, will last many years. USE ONLY KEATING SPATULAS. A sample of Keating Klenzer, Keating palmetto brush NOTE: Keating Klenzer MSDS Sheet is available and a 4” scraper are included with each new griddle. on-line. ® 1. Scra
ملخص المحتوى في الصفحة رقم 8
A. Griddle Surface CLEANING ® With proper care, the MIRACLEAN surface and its Proper care should be taken to fully clean the griddle unique cooking properties will last for many years. on a regular basis. However, nicks or dents in the griddle surface may cause the griddle surface to lift from the depressed DISCONNECT ELECTRIC POWER WARNING area. If nicks are close together, the surface may raise SOURCE BEFORE CLEANING. and be torn when a spatula or scraper is used. Care A. CONTROL PANEL - Clean
ملخص المحتوى في الصفحة رقم 9
V SERVICE DIAGNOSIS A. Trouble shooting The following diagnosis is only to be used as a guide to qualified personnel. Keating recommends that you use a qualified service company. Call 1-800-KEATING if you need assistance in locating a qualified service company. PROBLEM PROBABLE CAUSE SOLUTION Griddle won't heat. a No electricity to griddle. a. Connect griddle to an approved source of power. b Griddle circuit breakers (external) have tripped. b. Reset circuit breakers (External). c. On/Off switch
ملخص المحتوى في الصفحة رقم 10
A A T T H H I I T T 500 500 500 500 4450 50 4450 50 400 400 400 400 C C L L B B R R 350 350 350 350 VI PARTS LIST ORDERING PARTS Parts may be ordered by calling 1-800-KEATING or your local Keating service company. You may also order on- line at Keating’s part store, www.keatingofchicago.com ® Refer to the Keating MIRACLEAN Electric Griddle Limited Warranty for complete service and ordering information. The model/serial plate is located inside of the grease drawer area to the left or on the fron
ملخص المحتوى في الصفحة رقم 11
To replace thermostat: • Loosen nuts (#7) • Loosen nuts to Dispersion Plate (if needed) • Slide thermostat bulb through slots pictured in items 2, 3, & 4. • With bulb tight against the plate, tighten all nuts. Figure 6-3 Heating Element Assembly PART QTY 24" QTY 30" QTY 33" ITEM DESCRIPTION NUMBER DEEP DEEP DEEP 1 HEATING ELEMENT 2300W, 220V 002478 1 3000W, 220V 002483 1 3750W, 220V 002487 1 3300W,220V (HIGH INPUT, TEPPANYAKI) 002482 1 4370W, 220V (HIGH INPUT) 002480 1 3000W, 440V 013270 1 3750
ملخص المحتوى في الصفحة رقم 12
Assembly instructions for griddle stand on casters (There is no top on this stand) 10
ملخص المحتوى في الصفحة رقم 13
208 - 240 VOLT WIRING DIAGRAM (3-PHASE CONNECTIONS) 11
ملخص المحتوى في الصفحة رقم 14
208 - 240 VOLT WIRING DIAGRAM (SINGLE-PHASE CONNECTIONS) 12
ملخص المحتوى في الصفحة رقم 15
480 VOLT WIRING DIAGRAM NOTE: Griddles rated at 480 Volts use type D-1 thermostats which include On/Off switches. Separate On/Off switches are not provided with these griddles. 13
ملخص المحتوى في الصفحة رقم 16
VIII KEATING GRIDDLE SPECIFICATIONS MODELS: STANDARD & FRONT TROUGH ONLY 24" DEEP MODELS 27x24 30x24 36x24 AMPS AMPS AMPS PER LINE-THREE PHASE AMPS PER LINE-THREE PHASE VOLTS kW SINGLE VOLTS kW SINGLE L1 L2 L3 PHASE L1 L2 L3 PHASE 208 4.1 10 17 10 20 208 6.2 17 17 17 30 220 4.6 11 18 11 21 220 6.9 18 18 18 31 240 5.5 11 20 11 23 240 8.2 20 20 20 34 2 ELEMENTS (2300 W EACH) 3 ELEMENTS (2300 W EACH) 42x24 / 48x24 60x24 AMPS AMPS AMPS PER LINE-THREE PHASE AMPS PER LINE-THREE PHASE VOLTS kW SING
ملخص المحتوى في الصفحة رقم 17
MODELS: STANDARD & FRONT TROUGH ONLY 30" DEEP MODELS 24x30 27x30 30x30 36x30 AMPS PER LINE-THREE PHASE AMPS AMPS AMPS PER LINE-THREE PHASE VOLTS kW SINGLE VOLTS kW SINGLE L1 L2 L3 PHASE L1 L2 L3 PHASE 208 5.4 13 22 13 26 208 8.0 22 22 22 39 220 6.0 14 24 14 27 220 9.0 24 24 24 41 240 7.1 15 26 15 30 240 10.7 26 26 26 45 2 ELEMENTS (3000 W EACH) 3 ELEMENTS (3000 W EACH) 42x30 / 48x30 60x30 AMPS AMPS AMPS PER LINE-THREE PHASE AMPS PER LINE-THREE PHASE VOLTS kW SINGLE VOLTS kW SINGLE L1 L2 L3 P
ملخص المحتوى في الصفحة رقم 18
MODELS: STANDARD & FRONT TROUGH ONLY 36" DEEP MODELS 36x36 42x36 48x36 AMPS AMPS PER LINE-THREE PHASE AMPS AMPS PER LINE-THREE PHASE VOLTS kW SINGLE VOLTS kW SINGLE L1 L2 L3 PHASE L1 L2 L3 PHASE 208 10.1 28 28 28 48 208 13.4 43 43 28 65 220 11.3 30 30 30 51 220 15.0 45 45 30 68 240 13.4 32 32 32 56 240 17.9 49 49 32 75 3 ELEMENTS (3750 W EACH) 4 ELEMENTS (3750 W EACH) 60x36 72x36 AMPS AMPS AMPS PER LINE-THREE PHASE AMPS PER LINE-THREE PHASE VOLTS kW SINGLE VOLTS kW SINGLE L1 L2 L3 PHASE L1 L
ملخص المحتوى في الصفحة رقم 19
ملخص المحتوى في الصفحة رقم 20
SERVICE INFORMATION If you have a service related question call 1-800-KEATING. Please state the nature of the call; it will ensure speaking with the appropriate person. Have your serial and model number available when ordering parts. KEATING OF CHICAGO, INC. 8901 W. 50th Street, McCook, Illinios 60525-6001 Phone: (708) 246-3000 FAX: (708) 246-3100 Toll Free 1-800-KEATING (In U.S. and Canada) www.keatingofchicago.com *As continuous product improvement occurs, specifications may be changed witho
