ملخص المحتوى في الصفحة رقم 1
Installation and Operation Instructions
for
GAS-FIRED
Vented Gas Log Sets
Model OD24SHKN/P
DECORATIVE GAS APPLIANCE FOR INSTALLATION IN ODSR36/42A FIREPLACES
W A R N I N G
IF THE INFORMATION IN THIS MANUAL IS NOT FOLLOWED EXACTLY, A FIRE OR EXPLOSION MAY RESULT,
CAUSING PROPERTY DAMAGE, INJURY, OR LOSS OF LIFE.
FOR YOUR SAFETY:
DO NOT STORE GASOLINE OR OTHER FLAMMABLE VAPORS OR LIQUIDS NEAR THIS OR
ANY OTHER APPLIANCE.
WHAT TO DO IF YOU SMELL GAS:
• SHUT OFF ALL GAS TO THE APPLIANCE.
• D
ملخص المحتوى في الصفحة رقم 2
WARNING Improper installation, adjustment, alteration, service or maintenance can cause injury or property dam- age. Read these directions thoroughly before installation. For assistance or additional information, consult your gas log dealer, qualified installer, service agency or gas supplier. WARNING If not installed, operated, and maintained in accordance with the manufacturer’s instructions, this prod- uct could expose you to substances in fuel or fuel combustion which are known to the Sta
ملخص المحتوى في الصفحة رقم 3
General Information • WARNING: If the fireplace contains glass doors, In order to assure a safe and effective instal- they must remain open at all times during the opera- lation, only a qualified service person who is tion of the logset, allowing combustion air to circulate. familiar with the building codes and installation • In order to avoid any possible gas leaks, apply pipe techniques appropriate to your area may install joint compound to all non-flared threaded connections and service th
ملخص المحتوى في الصفحة رقم 4
Pre-Installation Checklist Yes No Is the gas type you are using the same as the gas type listed on the rating plate for this appliance? Does the firebox meet the minimum size dimensions below? Is the gas supply inlet pressure correct? Refer to Table below. Is your fireplace plumbed with gas on the right side (facing) of the fireplace? If not, refer to page 5. Is the gas supply line sized properly (Minimum 1/2” Iron pipe)? Do you have a solid fuel (wood burning) fireplace with a vented flue? Do yo
ملخص المحتوى في الصفحة رقم 5
4. Attach one end of the Flexible Gas Connector to the brass Burner Inlet Fitting which has been factory installed into the burner. 5. Attach the other end of the Gas Connector to the flared side of the Gas Supply Fitting. Remember to use pipe thread sealant or teflon tape only on the straight pipe threads. Do not use on any flared ends. CFM149 Fig. 2 Natural gas connection. Gas Plumbed on Left Hand Side of Fireplace CFM149 R-CFL Gas Supply Connection NOTE: Your gas log set is assembled at
ملخص المحتوى في الصفحة رقم 6
Leak Test Procedures After connecting the gas supply, test for leaks. Use a 50/50 solution of liquid soap and water to test for leaks at gas fitting and joints. Apply water/soap solution with brush only - do not over apply. NEVER test with an open flame. WARNING: DO NOT USE AN OPEN FLAME TO TEST FOR LEAKS! NOTE: Always perform a leak test any time the appliance has been moved or disconnected from the gas supply line. Damper Stop Installation
ملخص المحتوى في الصفحة رقم 7
Grate Placement Grate Assembly Place grate assembly over top of burner so the front middle leg of the grate is 1 ¹⁄₂” back from the front edge of the main burner pan assembly. (Fig. 7) Lava Rock Pan Assembly FP1488 Fig. 8 Lava rock placement. 1 ¹⁄₂" FP1487 Fig. 7 Grate placement. FP1488 OD24 lava rock Add Pan Material 5/10/04 djt 1. With burner pan and grate in place, open the Glowing Embers bag of lava rock and spread it evenly across the FP1489 pan assembly to the top of the pan assem
ملخص المحتوى في الصفحة رقم 8
Log Placement Optional Glass Door Set The optional glass door set is for weather exposure 1. Place the larger bottom logs (longer log in back, protection of gas logs for the ODSRA Series fireplaces. shorter (2) logs in front) onto the grate, leaving as much space between them as possible. (Fig. 12) CAUTION: The glass doors must be fully open when operating the gas log set. Unit Model ODSR36A 36GDKSSSR Back Log ODSR42A 42GDKSSSR Front (2) Shorter Logs Grate Retainer FP1149 Fig. 12 OD24SHK
ملخص المحتوى في الصفحة رقم 9
For Your Safety Read Before Lighting WARNING: If you do not follow these directions exactly, a fire or explosion may result caus- ing property damage, personal injury, or loss of life. What To Do If You Smell Gas • Do not try to light any appliance. • Do not touch any electrical switch, do not use any phone in the immediate area. • Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s instructions. • If you cannot reach your gas supplier, call the fire department.
ملخص المحتوى في الصفحة رقم 10
Troubleshooting Log Set Is Smoking/Sooting Excessively It is natural and unavoidable for vented gas log sets to produce moderate levels of carbon (soot) where flame contacts the logs. The logs can be cleaned using a soft-bristle brush. However, if soot is pro- duced where there is no flame impingement, one of the following may be the cause: Fireplace venting system not drafting properly: Make sure the damper is wide open at all times. Preheat the flue in very cold weather by burning the log se
ملخص المحتوى في الصفحة رقم 11
1d 2 1 1a 4 1b 1e 3 1 1 1c 10 9 14 5 15 12 7 16 17 8 13 6 7967 CFM Specialty Home Products reserves the right to make changes in design, materials, specifications, prices and discontinue colors and products at any time, without notice. OD24SHK Vented Gas Logs 7967 Ref. Description OD24SHK OD24SHK 1. Complete Log Set 20007970 P AR TS 1a. Top Log #3 5/04 NNS3 1b. Top Log (2) NNS4 1c. Rear Log 20007972 1d. Left Front Log 20007974 1e. Right Front Log 20007973 2. Bag of Glowing Embers 43
ملخص المحتوى في الصفحة رقم 12
LIMITED 2/20 YEAR WARRANTY For VERMONT CASTINGS Decorative Gas Appliances CFM Specialty Home Products extends the warranties ARE HEREBY EXPRESSLY INCLUDED. IN NO EVENT specified in paragraphs A and B below with respect to its SHALL ANY IMPLIED WARRANTY PRESCRIBED BY LAW Vermont Castings Decorative Gas Appliances (the “Gas Ap- (NOTWITHSTANDING THE FOREGOING EXPRESS EX- pliance”), including CFM Specialty Home Products supplied CLUSION) REMAIN IN EFFECT AFTER EXPIRATIONS OF accessories and co
