ملخص المحتوى في الصفحة رقم 1
R-110
TECHNICAL EDUCATION
2010 Whirlpool 26’
SXS Refrigerators
GSF26C5EXW GSS26C5XXW
GSF26C5EXY
GSS26C5XXY
GSS26C5XXA GSF26C5EXS
GSS26C5XXB GSF26C5EXT
JOB AID W10338921
ملخص المحتوى في الصفحة رقم 2
FORWARD This Job Aid, Whirlpool Gold 26’ SXS 2010 Part Number W10330404 has been compiled to provide the recent information on design, features, operation, troubleshooting and repair proce- dures for 26’ SXS for 2010. This Job Aid is not intended to replace or substitute for the Use and Care Guides or Tech Sheets associated with any of the models covered. Refer to the Technical Service sheet shipped with the refrigerator for detailed information for the unit you are servicing. GOALS A
ملخص المحتوى في الصفحة رقم 3
TABLE OF CONTENTS Page GENERAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-1 Safety ................................................................ 1-1 Introduction Specifications and Overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-2 SxS Model Number Interpretation .......................................... 1-3 6th Sense Technology ...........................................
ملخص المحتوى في الصفحة رقم 4
TABLE OF CONTENTS (continued) Door Open Alarm . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-9 Dispenser Lock . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-10 Cooling Off Mode .......................................................5-11 Cooling On Mode .......................................................5-11 Water Filter Status Light ...........................
ملخص المحتوى في الصفحة رقم 5
GENERAL Safety Observe all safety warnings and messages. The Use and Care manual and Installation instructions that come with the product as well as stickers and litera- ture attached to the refrigerator contain safety symbols. These symbols contain messages telling you of potential hazards and explain how to reduce your chance of injury. The message will also tell you what can happen if the instructions are not followed. Your safety and the safety of others are very important. We have prov
ملخص المحتوى في الصفحة رقم 6
Dimensions Inches. Introduction Specifications and Overview Capacity 26.360 26’ Dimensions Dimensions Inches. Carton Depth 35 Capacity 26.360 Dimensions Inches. Carton Height 71 1/4 Carton Depth 35 Capacity 26.360 Carton Width 38 Carton Height 71 1/4 Carton Depth 35 Cutout Depth (in) 29 13/16 Carton Width 38 Carton Height 71 1/4 Cutout Height (in) 69 5/16 Cutout Depth (in) 29 13/16 Carton Width 38 Cutout Width (in) 36 1/16 Cutout Height (in) 69 5/16 Cutout Depth (in) 29 13/16 Depth 36 Cutout Wi
ملخص المحتوى في الصفحة رقم 7
1-3
ملخص المحتوى في الصفحة رقم 8
Introduction Specifications and Overview (continued) th 6 Sense Technology th 6 Sense software makes an estimation of the actual food temperature inside the refrig- erator and freezer compartment and adjusts cooling to allow the food packages to return their initial temperature faster during pull th down, door openings, or heavy food load. 6 Sense algorithm runs in both freezer com- partment and refrigerator compartment and each contains 3 routines: Trigger, Package Estimator, and Def
ملخص المحتوى في الصفحة رقم 9
INSTALLATION REQUIREMENTS Installation Instructions This new SXS platform requires different installation steps and adjustments than current SXS refrigerators. Review the Use and Care manual and instruction sheets shipped with the product prior to installation. See the following examples: Door Removal, Leveling and Alignment hex 2-1
ملخص المحتوى في الصفحة رقم 10
Installation Instructions (continued) Installation - Example hex 2-2
ملخص المحتوى في الصفحة رقم 11
Installation Instructions (continued) Installation - Example (continued) 2-3
ملخص المحتوى في الصفحة رقم 12
Installation Refrigerators are shipped with the handles packed in the refrigerator door. 1. Remove the handles from the door and unwrap. 1 2. The instruction sheet and a Hex key tool are attached to the handle. Review the instruction sheet. 2 3. Install the handle on the mounting studs with the hex screws facing to the center. 3 4. Hold the handle tight against the door as you tighten the screws. The handle will pull in tight against the door as the screw is tightened. 4 2-
ملخص المحتوى في الصفحة رقم 13
Installation Instructions (continued) Installation (continued) Removing Grille WARNING Electrical Shock Hazard Disconnect power before servicing. Replace all parts and panels before operating. Failure to do so can result in death or electrical shock. 1. Disconnect power to the refrigerator. Remove 2 ¼” screws The grille is held in place with 2 ¼” screws. 2. Remove screws 2 Remove grille 3. Open the doors 90 degrees perpendicular 3 to the cabinet to remove the
ملخص المحتوى في الصفحة رقم 14
Installation Instructions (continued) Removing Freezer Door WARNING Electrical Shock Hazard Disconnect power before servicing. 2 Replace all parts and panels before operating. Failure to do so can result in death or electrical shock. 1. Unplug or disconnect the refrigerator from the power supply. 3. Disconnect water tubes form the door side of the connector 2. Remove the screws securing the wire harnesses to the cabinet. 3 2 3. Disconnect water tubes form the door side of the c
ملخص المحتوى في الصفحة رقم 15
Installation Instructions (continued) Removing Freezer Door Upper Hinge 6. Remove Two 3/16” hex key screws (A). Do not remove or loosen the other A two screws (B). B B A 7. Keep the door closed and lift off the hinge. 5 6 WARNING Excessive Weight Hazard Use two or more people to lift the freezer door. Failure to do so can result in back or Lift off the hinge other injury. 6 7 8. Have another person open the freezer door and lift up slowly. 7 8 9. As the door is lifted guide
ملخص المحتوى في الصفحة رقم 16
—NOTES— 2-8
ملخص المحتوى في الصفحة رقم 17
REFRIGERATOR COMPONENTS Refrigerator Compartment Light Bulbs Water Filter Air Damper Air Filter Disassembling Refrigerator Compartment Components WARNING 2 1 Electrical Shock Hazard Disconnect power before servicing. Replace all parts and panels before operating. Failure to do so can result in death or electrical shock. 1. Disconnect power to the refrigerator. 3 2 2. Open the water filter door and remove the filter. 3. Open the air filter door and remove the filter. 4. Remove th
ملخص المحتوى في الصفحة رقم 18
1 2 Refrigerator Compartment (continued) 3 5. Remove the air damper cover. 5 4 6. Remove the ¼” screw securing the air filter housing to the cabinet and remove. 6 5 7. Disconnect the wiring harness and remove the air damper assembly. 7 6 8. Check the seal around the damper housing for any damage or misplace ment. Replace or reposition seal as needed. 8 7 3-2
ملخص المحتوى في الصفحة رقم 19
Refrigerator Compartment (continued) Disassembling Refrigerator Compartment Components – Water Filter Housing Remove the water filter as explained earlier. 1. Remove the ¼” screw securing the filter cover to the filter body. 1 2. Remove the cover. 2 3. Remove the ¼” screw securing the filter body to the cabinet wall. 3 4. To replace the filter housing, disconnect the water tubes in the back of the refrigerator and remove Permagum seal. Pull the filter housing and water
ملخص المحتوى في الصفحة رقم 20
Refrigerator Compartment (continued) Refrigerator Thermistor The refrigerator Thermistor is a variable resistance device connected to the control board. The temperature of the refrigerator compartment causes the resistance of the Thermistor to change. The resistance is monitored by a circuit on the control board which controls the opera- tion of the cooling system. The Thermistor is located on the right side of the refrigerator cabinet th attached to the back of the cover labeled 6 sense. R
