ملخص المحتوى في الصفحة رقم 1
SE_AR8
OWNERS
MANUAL
CRAFTSMAN
COMPACT AIR COMPRESSOR
MODEL NO.
919,150270
Listed
7"21Y
Record In the spaces provided.
Air
Compressor
(1) The model number which can be
found On the Io1_1 on the back of tha
unit.
(2) The date €ode number which can be
found on t_e foil lahet on me bottom
of the unlL
ASSEMBLY
IMPORTANT
OPERATION
Retain mue numbers for future
MAINTENANCE
Read the Safety Guideline=;
refelr_,
REPAIR PARTS
and All Instructions
Carefully Before Operstlng
Sears, Roebuck and Co., Chicago,
ملخص المحتوى في الصفحة رقم 2
TABLE OF CONTENTS WARRANTY ....................................................... 3 SAFETY GUIDELINES AND CHART .............................. 3 WARNING CHART ................................................. 4 SPECIFICATION CHART .......................................... s .GLOSSARY ........................................................ ,5 GENERAL INFORMATION ........................................ 5 DESCRIPTION OF OPERATION .................................. 5 UNPACKING INSTRUCTIONS .....
ملخص المحتوى في الصفحة رقم 3
FULL ONE YEAR WARRANTY ON AIR COMPRESSORS If this air compressor fails due to a def_-t in material or workmanship within one year from the date of purchase, return it to the nearest Sears Service Canter/Department throughout the United States and Sears will repair it, free of charge. If this air compressor is used for commercial or rental purposes, the warranty will apply for ninety days from the date of purchase, This warranty gives you specifm legal rights and you may have other rights which v
ملخص المحتوى في الصفحة رقم 4
HAZARDS CAN OCCUR IF EQUIPMENT IS NOT USED PROPERLY. READ THE FOLLOWING CHART N, , ,,,,,,, ,,,,,,,i ,,,,,,,,, ,1111 WHAT TO LOOK FOR HOW TO PREVENT IT Hot Parts The top of the compressor gets Nevertouchthetopoftheaircompressor during hot when the compresSOr is run- or immediately after operation. Always use the ning. If you touch it, you may be handle, seriously burned. Flammabie _/a_ It is normal for the motor's etectri- The air compressor must only be used in well cal contacts to spark when th
ملخص المحتوى في الصفحة رقم 5
SPECIFICATION CHART Model No. 919.1S0270 Horsepower _/, SCFM @ 40 psig 2.7 SCFM @ 9O psig 2.0 Disptecement CFM 4.0 Bore 2%" Stroke ,9" Voltage-Single Phase 110-120 Minimum Branch Circuit Requtrem_mt 15 AMPS "Fuse Type Time Delay Amperage at Max. Pressure 10.6 "A circuit breaker is preferred. Use only a fuse or circuit breaker that is the same rating as the branch cimult the air compressor is operated on. If the air compressor is connected to a circuit pmtented by fuses, use time delay fuses. GLO
ملخص المحتوى في الصفحة رقم 6
INSTRUCTIONS Tools Needed for Unpacking Note the plastic brace attached to the air compres_ A +/2"socket wrench. sot"by a hex screw, Using a _h" socket wrench, remove the hex screw. Dlacard both the screw and the plastic Grasp the handle _undlift the air compressor out of the brace. carton. Remove the styrofoam and plastic brace. ASSEMBLY INSTRUCTIONS . Tools Needed for Assembly Turn your compressor on its side. 2, A phillips screwdriver. insert eyelet into rubber fool 3, Center hole in rubber f
ملخص المحتوى في الصفحة رقم 7
OPERATING PROCEDURES 7. Slowly Jr=creasethe pressure setting ofthe adjuatabI 1. Before plugging inthe air compressor, set the adjust- pressure valve. You should be able to hear and fe, able pressure valve to =Start-. Make sure the _ON- OFF* switch is in the "OFF" position. air pressure being relieved by the adjustable pressu_ valve. If pressure is not being relieved, turn the a 2. Connect the air hose to the air outtetaclapter.Tighten compressor off immediately. The pressure valv securely. must
ملخص المحتوى في الصفحة رقم 8
STORAGE Motor I_eplaP.,ement - Wiring Diagram m./_ K .... Conna=t When you have finished using the air c0mp_ssOr:. IG - s._ 1. Set the "ON-OFF" switch to _OFF" and unplug the ' cord. 2. Relieve all pressure from the air ¢ompressor head and air hose by turning the adjustable pressure valve to the "Start" position. =i! ii! 3. Protect the electrical cord and air hose frOmdamage by winding them loosely around the air compressor. 1;= I tP, 4. Store the air compressor in a clean arid dry location. I L
ملخص المحتوى في الصفحة رقم 9
TROUBLESHOOTING GUIDE WAINING F ,,,,,, ., i I IIIIIIII VOLTAGE SOURCES, MOVING PARTS, OR COMPRESSED AIR SOURCES ARE EXPOSED WHEN REPAIRING THE COMPRESSOR. PERSONAL INJURY CAN OCCUR. UNPLUG THE COMPRES- SOR AND BLEED OFF ALL AIR PRESSURE BY TURNING THE ADJUSTABLE PRESSURE VALVE TO THE START POSITION BEFORE ATTEMPTING ANY REPAIRS. I_EM "' i ,,,,,,,,, ,,,,,,,,,, ,,,,,,,,, ,,11 ,,, i PROB CAUSE CORRECTION ....... ,,,, i ,,,,,,,,,., ,,,,,, i ,,,,,,,,,,,ll Air Leaks Hose firing loose, ,,,,,Tightentiff
ملخص المحتوى في الصفحة رقم 10
NR COMPRESSOR DIAGRAM [ s L 14 17 15 16 22 21 PARTS LIST KEY KEY NO. PARTNUMBER mESCRFTION NO. PART NUMBER DESCRIPTION 1 Not used 13 SSW-_J67 SWain relief 2 LA-G25 Hot surfaea label 14 SSS-lS Switch 3 SSF-8129-ZN lS CAC-348-1 Locimut 1/,_-20 (2 used) Terminal be0( cover 4 Not used 16 CAC-4252 Cordmemb;y 5 LA-1780-1 17 Warning label CAC-4231 Jumper wire 6 CAC-4259 18 TIA-4378 Rear shroud assembly Adjustable pressure valve 7 19 LA-1787 Sears logo label - Performance labal :0 not available SSF_131
ملخص المحتوى في الصفحة رقم 11
COMPRESSOR PUMP OIAGRAM PARTS LIST KEY NO. PART NUMBER DESCRIPTION 26 26 CAC-280-2 Filter 27 27 CAC-1018 Intake muffler 28 Not used 29 Not used 30 SSF-2043 Set screw 31 SSF-6637 Shoulder stud _':20 x 11/e" 31A (2 used) 31A SSF-927 Screw %%20 x 11/8" (2used) *,'n,'32 CAC-4234 Head essy. 33 CAC-245-1 Flapper valve intake SSF-98_! Screw #5-40 x _/4" (3 used) 35 CAC-251-2 Gasket 36 CAC-38g Restrlntor 37 CAC-246-3 Flapper valve exhaust "_'_ 38 CAC.4203-1 Valve plate assy. 39 SSG-8133 O-ring J" 40 CAC
