ملخص المحتوى في الصفحة رقم 1
INSTALLATION &
OPERATION MANUAL
TM
SCALEBLOCKER
WATER FILTRATION SYSTEM
MODEL PART NO.
SPS600V 854893-1
SPS620V 854893-2
For additional information on Vulcan-Hart or to locate an authorized parts
and service provider in your area, visit our website at www.vulcanhart.com
VULCAN-HART P.O. BOX 696, LOUISVILLE, KY 40201-0696
DIVISION OF ITW FOOD EQUIPMENT GROUP, LLC TEL. (502) 778-2791
WWW.VULCANHART.COM FORM 31228 Rev.A (Sept. 2004)
ملخص المحتوى في الصفحة رقم 2
Installation, Operation and Care of TM SCALEBLOCKER WATER FILTRATION SYSTEM MODELS SPS600V & SPS620V SAVE THESE INSTRUCTIONS GENERAL Vulcan water filters are produced with quality workmanship and material. Proper installation, usage and maintenance of your water filter will result in many years of satisfactory performance. It is suggested that you thoroughly read this entire manual and carefully follow all of the instructions provided. The water filtration system conforms to ANSI/NSF Standard 5
ملخص المحتوى في الصفحة رقم 3
INSTALLATION REQUIREMENTS WATER PARAMETERS The model SPS600V and SPS620V water filters are designed to be pH 6 to 9 installed in the cold water line only. Installation of the water filter in Alkalinity 0 to 250 ppm a hot water line can seriously damage the filter housing. The filter Chlorine 0 to 4 ppm must be in contact with water at all times after installation. Installation Hardness 0 to 300 ppm must comply with any existing state or local plumbing codes. Refer to the Water Parameters tabl
ملخص المحتوى في الصفحة رقم 4
OPERATION WATER FILTER BATTERIES + The proper water filter cartridge should already + be installed in the filter housing. Make sure the COVER filter housing is firmly screwed into the filter 1234567 123 1234 1234567 1234 mounting head. Use the supplied wrench if necessary. Turn on the filter water supply valve. Press the red pressure relief button on top of the DISPLAY filter mounting head until all air is purged from Digital Flow Meter the filter. RESET DIGITAL FLOW METER Fig. 2 Installing Ba
ملخص المحتوى في الصفحة رقم 5
MAINTENANCE ORDERING PREVENTIVE MAINTENANCE KITS FILTER CARTRIDGE REPLACEMENT (PM) KITS To order the Preventive Maintenance Kit for your Filter Filter ScaleBlocker PM filtration system, contact your Vulcan Model Height Preventive Maintenance Kit representative, the Vulcan-Hart Service Part Number Department (at the address or phone number on SPS600V 10" 854306-4 the cover of this document) or visit Vulcan online SPS620V 20" 854306-13 www.vulcanhart.com and click on Service. at Refer to the part
ملخص المحتوى في الصفحة رقم 6
TM USING SCALEBLOCKER RELEASE Do not use alcohol-based cleaners. Clean the inside of the filter housing with a mild soap. Inspect the O-Rings for damage and replace if necessary. Wipe the large black O-Ring clean with a rag, press it down into the groove and then apply a very light coating of white petroleum jelly (Vaseline). Make sure the O-Ring fits in the groove and is properly seated each time the filter is reassembled, otherwise a water leak could occur. With the filter removed, insert th
ملخص المحتوى في الصفحة رقم 7
TROUBLESHOOTING SYMPTOM POSSIBLE CAUSE SUGGESTED CORRECTIVE ACTION Short filter life. Filter clogs due to excessive particles in water. An additional filter may be needed. Low incoming water pressure. Check water source. Excessively hard water or water quality beyond Additional water treatment may be needed specification. before filter. Filtered water not going to boiler feed line. Check plumbing lines. A leaking Fill Valve on the steamer equipment Contact Service (to replace valve) if water wil
ملخص المحتوى في الصفحة رقم 8
Model SPS620V, Part No. 854893-2 Part No. Name Qty. 854306-1 Backplate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 854893-7 Clear Housing, 20" . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 854306-3 U-Bracket, Large . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 854893-8 O-Ring, Large, Black . . . . . .
