ملخص المحتوى في الصفحة رقم 1
Low--Ambient KSALA0201R22
PressureSwitch KSALA0301410
Installation Instructions
NOTE: Read the entire instruction manual before starting the DESCRIPTIONANDUSAGE
installation.
Thelow--ambientpressureswitch kit isa long life pressureswitch
which turns the fan on and offas shown in Table1. Itis wired in
SAFETYCONSIDERATIONS
series with black fan lead. Sleeve--bearing motors can be used
Improper installation, adjustment, alteration, service,
with this control.
maintenance, or use can cause explosion
ملخص المحتوى في الصفحة رقم 2
Table1—KitUsageandCutIn/CutOutPressures KITPARTNO. REFRIGERANT PRESSURESWITCHCLOSES PRESSURESWITCHOPENS WIRECOLORS (PSIG) (PSIG) KSALA0201R22 R---22 225 100 Blue and Yellow KSALA0301410 R---410A 365 200 Blue and Violet SERVICE FITTING CAP CONNECTOR VALVE CORE END BLACK FLARE NUT ON PRESSURE ADAPTER TEE SWITCH CONTACTOR FAN MOTOR YELLOW OR EXTENDER TUBE BLUE VIOLET FLARE NUT PRESSURE SWITCH LIQUID REFRIGERANT SERVICE VALVE SERVICE FITTING A97326 A00025 Fig.2 — PowerWiringforAllVoltagesof Fig.1 —
ملخص المحتوى في الصفحة رقم 3
START--UP To start units equipped with the low--ambient pressure switch, T perform the following steps: 1. Turn poweron to unit. TDR 2. Setthermostatbelow room temperature. 3. Wait for the unit to start. There may be a 5--minute delay in thethermostatorin theoutdoorunit. 4. Observeunitoperation asdescribed below. a. Thefan willbeoffwhen compressorstarts. C b. Atoutdoortemperaturesaround 0_F, fan may not run at all. LPS c. At summer temperatures, fan will start after 10 to 30 LPS LOW-PRESSURE SWI
ملخص المحتوى في الصفحة رقم 4
7 3 /32″ x /8″ (5.56 x 9.53) SLOT 4 REQ'D 9 / ″ (3.45) DIA HOLE 64 2 REQ'D H 3 / ″ 8 1 6 / ″ 16 (9.6) (154.0) TYP J G 1 / ″ 2 (12.7) SUPPORT TYP MAT'L: 18 GA STEEL 7 / ″ 16 C (11.6) TYP E A 1 / ″ 2 (12.7) TYP 9 / ″ (3.45) DIA HOLE 64 1 REQ'D K 7 B / ″ 16 (11.6) J TYP 7 / ″ (5.56) DIA HOLE 32 3 REQ'D 1 /4″ 1 / ″ M 4 (6.3) (6.3) L TYP TYP D 7 / ″ x 2″ 32 BAFFLE (5.56 x 50.8) SLOT MAT'L: 20 GA STEEL SCREW 10 REQ'D F SUPPORT 4 REQ'D OUTDOOR AA BAFFLE UNIT 2 REQ'D BAFFLE ASSEMBLY A95444
ملخص المحتوى في الصفحة رقم 5
5 WindBaffleDimensionsforCarrierWeatherMakerUnits—38TKB,38TKW,38YKC (In.) Unit AA Unit A B C D E F G H J K L M Size Height 21---7/8 17 25---1/4 10---3/8 19---3/4 20---1/2 34 19---11/16 20---7/16 19---5/8 0 0 6---1/8 Small 27---1/2 25---7/8 17 25---1/4 10---3/8 23---3/4 24---1/2 34 23---11/16 24---7/16 23---5/8 0 11---7/8 6---1/8 31---7/8 17 25---1/4 10---3/8 29---3/4 30---1/2 34 29---11/16 30---7/16 29---5/8 0 14---7/8 6---1/8 25---7/8 21 32 11---3/16 23---3/4 24---1/2 42 23---11/16 24---7/16 23
ملخص المحتوى في الصفحة رقم 6
1 3 / ″ x / ″ (5.56 x 9.53) SLOT 4 8 4 REQ'D 1 / ″ (3.45) DIA HOLE 8 2 REQ'D H 3 / ″ 8 5 5 / ″ 16 (9.6) 1 / ″ (5.56) DIA HOLE 2 REQ'D 4 (151.5) J G 1 / ″ 2 (12.7) SUPPORT TYP MAT'L: 18 GA STEEL 7 / ″ 16 C (11.6) E A 1 / ″ 2 (12.7) 1 / ″ (3.45) DIA HOLE 8 1 REQ'D K 7 B / ″ 16 (11.6) J 1 / ″ (5.56) DIA HOLE 4 3 REQ'D 1 / ″ 3 6″ 4 / ″ (9.6) 8 (152.4) (6.3) L D 1 / ″ x 2″ 4 BAFFLE (5.56 x 50.8) SLOT MAT'L: 20 GA STEEL SCREW 10 REQ'D F SUPPORT 4 REQ'D AA OUTDOOR UNIT BAFFLE 2 REQ'D BAFFL
ملخص المحتوى في الصفحة رقم 7
7 WindBaffleDimensionsfor10SeerBryantReliantUnitswithStar--BurstTop (In.) Unit AA Unit A B C D E F G H J K L Size Height 21---7/8 17---1/4 24---5/16 10---1/4 19---3/4 20---1/2 34---1/2 19---5/8 20---3/8 19---5/8 0 0 Small 26---3/16 25---7/8 17---1/4 24---5/16 10---1/4 23---3/4 24---1/2 34---1/2 23---5/8 24---3/8 23---5/8 0 11---7/8 31---7/8 17---1/4 24---5/16 10---1/4 29---3/4 30---1/2 34---1/2 29---5/8 30---3/8 29---5/8 0 14---7/8 25---7/8 21 30---5/8 10---1/4 23---3/4 24---1/2 42 23---5/8 24--
ملخص المحتوى في الصفحة رقم 8
7 3 1 7 / ″ / ″ / ″ (3.45) DIA 8 16 8 (200.0) (4.6) 2 REQ'D F 3 5 / ″ 64 E (128.0) C C 1 / ″ 2 E 1 / ″ 4 (12.7) (6.4) 3 5 / ″ 64 (128.0) 13 / ″ 64 1 / ″ (5.4) 2 7 B 29 7 / ″ 7 / ″ (200.8) 8 32 (12.7) TYP BAFFLE - LEFT (199.9) 25 / ″ (10.0) 64 TYP 21 MAT'L: 20 GA STEEL 1 / ″ (42.1) 32 BAFFLE - RIGHT MAT'L: 20 GA STEEL D 1 2 / ″ 1 2 / ″ (5.56) DIA 4 A (63.5) 2 REQ'D 1 2 / ″ A 1 3 2 / ″ x / ″ (5.56 x 9.53) SLOT 4 8 (63.5) 6 REQ'D D 1 / ″ (5.56) DIA 4 4 REQ'D 21 1 / ″ (42.1) 32
ملخص المحتوى في الصفحة رقم 9
9 WindBaffle Dimensionsfor Carrier / Bryant / Payne Cube Unitswith3/8” Coil Tubing (In.) Unit AA Unit A B C D E F G H J Size Height 21---15/16 19---7/8 13---3/4 28---1/8 10---11/16 20---1/4 11---11/16 3---13/16 19---13/16 17---13/16 23---15/16 21---7/8 13---3/4 28---1/8 10---11/16 20---1/4 11---11/16 3---13/16 21---13/16 19---13/16 25---15/16 23---7/8 13---3/4 28---1/8 10---11/16 20---1/4 11---11/16 3---13/16 23---13/16 21---13/16 Small 18 27---15/16 25---7/8 13---3/4 28---1/8 10---11/16 20---1/
ملخص المحتوى في الصفحة رقم 10
1″ (25.4) C 1 5 / ″ 5 / ″ 2 16 D (12.7) (134.2) E F 3 / ″ 1 8 /2″ (10.3) (12.7) 1 1 /4″ (6.35) x /2″ (12.7) SLOT (2) REQ'D 3 / ″ 8 1 / ″ 2 (10.3) (12.7) A B 7 / ″ 16 (11.8) H 7 1 3 / ″ /4″ (6.35) x /4″ (19.05) SLOT 16 G (11.8) (15) REQ'D WIND BAFFLE 7 / ″ 16 3 / ″ 8 (11.8) (10.3) 1 / ″ 2 (12.7) WIND BAFFLE 1 /8″ (3.45) DIA HOLE (3) REQ'D BAFFLE SUPPORT A SUPPORT A 1″ (25.4) BAFFLE SUPPORT B 5 5 / ″ 16 (134.2) 1 1 /4″ (6.35) x /2″ (12.7) SLOT (2) REQ'D 3 / ″ 8 1 AA / ″ 2 (10.3) (12.7) 7 / ″ 16 (
ملخص المحتوى في الصفحة رقم 11
11 WindBaffleDimensionsforPayneModelPA10/PA12AirConditioningUnits (In.) UnitSize AA UnitHeight A B C D E F G H J 21---15/16 18---11/16 9---5/16 81---1/2 67---7/8 41---13/16 15---13/16 18---11/16 9---5/16 10---13/16 23---15/16 20---11/16 10---5/16 81---1/2 67---7/8 41---13/16 15---13/16 18---11/16 10---5/16 10---13/16 25---15/16 22---11/16 11---5/16 81---1/2 67---7/8 41---13/16 15---13/16 18---11/16 11---5/16 10---13/16 Medium 22---1/2 27---15/16 24---11/16 12---5/16 81---1/2 67---7/8 41---13/16
ملخص المحتوى في الصفحة رقم 12
A06235 Fig.10 --- Base/Comfortt/Legacyt UnitsBaffleAssembly 12 KSALA
ملخص المحتوى في الصفحة رقم 13
13 WindBaffle Dimensionsfor Base / Comfortt / Legacyt Units (In.) UnitSize AA Unit A B C---1 C---2 C---3 D Height 25 20---3/8 10---1/16 3---15/16 10---7/8 6---1/8 41---7/8 28---7/16 23---13/16 11---3/4 3---15/16 10---7/8 6---1/8 41---7/8 31---13/16 27---3/16 13---1/2 3---15/16 10---7/8 6---1/8 41---7/8 Small 25---3/4 35---1/4 30---5/8 15---3/16 3---15/16 10---7/8 6---1/8 41---7/8 38---5/8 34 16---7/8 3---15/16 10---7/8 6---1/8 41---7/8 42 37---3/8 18---9/16 3---15/16 10---7/8 6---1/8 41---7/8 45
ملخص المحتوى في الصفحة رقم 14
BAFFLE-1 MATL: 20 GA STEEL A06231 BAFFLE ASSEMBLY A06230 Fig.11 --- Performancet and Preferredt SeriesBaffleAssemblies 14 KSALA
ملخص المحتوى في الصفحة رقم 15
BAFFLE-2 MATL: 20 GA STEEL A06232 BAFFLE-3 MAT'L: 20 GA STEEL A06234 Fig.12 --- Performancet and PreferredtSeriesBaffleAssemblies(continued) 15 KSALA
ملخص المحتوى في الصفحة رقم 16
SUPPORT MAT'L: 20 GA STEEL A06233 Fig.13 --- Performancet and PreferredtSeriesBaffleAssemblies(continued) 16 KSALA
ملخص المحتوى في الصفحة رقم 17
17 WindBaffle Dimensionsfor Performancet SeriesUnits UnitSize AA Unit A B C D E F G H Height (In.) (In.) (In.) (degrees) (In.) (degrees) (In.) (In.) 29---1/2 23---13/16 11---7/8 16 81.9 16---3/8 80.3 12---3/4 45---7/8 32---15/16 27---3/16 13---5/8 16 81.9 16---3/8 80.3 12---3/4 45---7/8 36---5/16 30---5/8 15---5/16 16 81.9 16---3/8 80.3 12---3/4 45---7/8 39---3/4 34 17 16 81.9 16---3/8 80.3 12---3/4 45---7/8 Medium 33 43---1/8 37---3/8 18---11/16 16 81.9 16---3/8 80.3 12---3/4 45---7/8 46---1/2
ملخص المحتوى في الصفحة رقم 18
Copyright2006CAC/BDPS 7310W.MorrisSt.S Indianapolis,IN 46231 Printed in U.S.A. Edition Date:5/06 Catalog No:AG--SALA--07 Manufacturerreservestherighttochange,atanytime,specificationsanddesignswithoutnoticeandwithoutobligations. Replaces:AG--SALA--05 18 KSALA
