Dixon 13632-0702 دليل المستخدم

ملخص المحتوى في الصفحة رقم 1

4000 SERIES
ZTR®
OPERATOR’S MANUAL
2003

ملخص المحتوى في الصفحة رقم 2

IMPORTANT - READ CAREFULLY ® ® The Dixon ZTR Mower is both easy and fun to operate. However, any power mower must be operated properly to be safe. It is not a toy or a recreational vehicle. Before you start to use the mower, read the operator’s manual carefully and become completely familiar with the controls. The information contained in this manual applies to all ® ® Dixon ZTR 4000 Series Mowers. Your Dixon dealer will gladly answer any questions. See your dealer for warranty service, par

ملخص المحتوى في الصفحة رقم 3

INDEX Page Safety. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-11 Warranty Policy. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12 Specifications. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13 Seat Adjustment Instructions. . . . . . . . . . . . . . . . . . . . . . . . .14 Controls. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .15-17 Operation Instructions. . . . . . . . . . . . . . . . . . . 18-27 Care & Maintenan

ملخص المحتوى في الصفحة رقم 4

SAFETY RIDING LAWN MOWERS, IF IMPROPERLY OPERATED, CAN CAUSE SERIOUS INJURY OR DEATH. The most common causes of injury to the operator or bystander... BLADE CONTACT TIP OVER RUN OVER BACK OVER ...read and understand this manual to prevent injuries. 4

ملخص المحتوى في الصفحة رقم 5

SAFETY Safety Alert Symbol When you see this symbol, BE ALERT to the potential for injury. Follow recommended safety precautions and safe operating practices. DANGER (highlighted in red) indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury. WARNING (highlighted in orange) indicates a potentially hazardous situation which, if not avoided, could result in death or serious injury. CAUTION (highlighted in yellow) indicates a potentially hazardous

ملخص المحتوى في الصفحة رقم 6

SAFETY Failure to observe the following safety instructions could result in serious injury or death. GENERAL OPERATION: •Read, understand, and follow all instructions in the manual and on the mower before starting. •Only allow responsible adults, who are familiar with the instructions, to operate the mower. •Clear the area of objects such as rocks, toys, wire, etc., which could be picked up & thrown by the blade. •Be sure the area is clear of other people before mowing. Stop mower if anyone

ملخص المحتوى في الصفحة رقم 7

SAFETY GENERAL OPERATION (continued): •Turn off blades when not mowing. •Stop engine before removing grass catcher or unclogging chute. •Mow only in daylight or good artificial light. •Do not operate the mower while under the influence of alcohol or drugs. •Watch for traffic when operating near or crossing roadways. •Use extra care when loading or unloading the mower into a trailer or truck. Do not ride the mower when loading and unloading. •Always wear safety goggles or safety glasses wi

ملخص المحتوى في الصفحة رقم 8

SAFETY SLOPE OPERATION: Slopes are a major factor related to loss-of-control and tip-over accidents, which can result in severe injury or death. All slopes require extra caution. If you cannot back up the slope or if you feel uneasy on it, do not mow it! DO •Mow across the slope with your Dixon ZTR - never up or down. •Remove obstacles such as rocks, tree limbs, etc. •Watch for holes, ruts or bumps. Uneven terrain could overturn the mower. Tall grass can hide obstacles. •Use slow speed. Tires

ملخص المحتوى في الصفحة رقم 9

SAFETY CHILDREN: Tragic accidents can occur if the operator is not alert to the presence of children. Children are attracted to lawn mowers and the mowing activity. NEVER assume children will stay where they were last seen. Be alert to avoid accidents. •Keep children out of the mowing area and under the watchful care of another responsible adult. •Be alert and turn mower off if a child enters the area. •Before and during backing, look BEHIND and DOWN for small children. •Never carry children.

ملخص المحتوى في الصفحة رقم 10

SAFETY SERVICE: •Use extra care in handling gasoline and other fuels. They are flammable and vapors are explosive. Use only an approved container. Never remove fuel cap or add fuel with engine running. Allow engine to cool before refueling. Do not smoke while refueling. Never refuel the mower indoors. Never store the mower or fuel container inside a building where there is an open flame. If fuel is spilled on clothing, change clothing immediately. To prevent fire and explosion caused by static

ملخص المحتوى في الصفحة رقم 11

SAFETY SERVICE (continued): •Never run a mower inside a closed area. The exhaust fumes are toxic. •Keep nuts and bolts tight, especially blade attachment bolts, and keep equipment in good condition. •Never tamper with safety devices. Check their proper operation regularly. •Keep mower free of grass, leaves, or other debris build- up. Clean up oil or fuel spillage. Allow mower to cool before storing. •Stop and inspect the equipment if you strike an object. Repair, if necessary, before re

ملخص المحتوى في الصفحة رقم 12

DIXON PROTECTION PLUS TWO YEAR LIMITED WARRANTY TRANSAXLE MODELS WARRANTY: Home Owner Application: Dixon Transaxle Models, used only at owner’s primary place of residence are warranted for a period of two (2) years from date of purchase. Commercial Application: defined as use other than, or in addition to, mowing at owner’s primary place of residence. Dixon Transaxle Models, used in commercial application are warranted for a period of (30) days from the date of purchase. DIXON ZTR MOWERS A

ملخص المحتوى في الصفحة رقم 13

SPECIFICATIONS Model ZTR 4423 CHASSIS: Twin 12 gauge side frames and 7 gauge transmission and engine base plate. BODY: All body parts made of high density polyethylene. Dent and corrosion resistant. MOWER DECK: 13 GA stamped steel construction. Three blades combine for a 42” cut width. Cut height approximately 1-1/2”- 4” via 7-position lift handle. BLADE DRIVE: Electric clutch. TRANSMISSION: Each rear wheel is independently driven by chain and sprockets through a mechanical friction drive. ENGI

ملخص المحتوى في الصفحة رقم 14

SEAT ADJUSTMENT INSTRUCTIONS Model ZTR 4423 1. Raise and push seat assembly forward. 2. Loosen five nuts and slide seat forward or backward to desired position. 3. Re-tighten nuts. DO NOT operate mower without seat adjustments properly tightened. 4. Push seat assembly back to closed position. 14

ملخص المحتوى في الصفحة رقم 15

CONTROLS The Dixon ZTR has a unique transaxle that requires only two drive levers to control braking, turning, speed and direction. On initial operation, set throttle speed on slow. Operate with mower blade in “OFF” position. To avoid “over-controlling” the mower, use a light touch on the drive levers. Slight movements using fingertip control is all that is necessary. PARKING BRAKE: The parking brake is designed to hold the mower from moving and is not intended for use in stopping the mower whi

ملخص المحتوى في الصفحة رقم 16

CONTROLS CONTROL LEVERS Note: For access to the seat, move control levers to neutral position and swing them outward. TO GO FORWARD: •From neutral position, gently push both control levers forward. •To increase speed, move levers further forward. TO GO BACKWARD: •From neutral position, gently pull both control levers toward you. TURNING: •Turning is controlled by moving one control lever slightly forward or rearward of the other. •To turn left, move left lever rearward of the right lever. •To

ملخص المحتوى في الصفحة رقم 17

CONTROLS BLADE DRIVE: •Located on the control panel, on the operator’s right. •To engage the mower blades, pull up on the switch. •To disengage mower blade, push down. CIRCUIT BREAKER: •Protection of the electrical system is by (1) 15 amp circuit breaker. •If circuit breaker trips, push button to reset. •If this condition repeats, consult dealer for inspection and repair. THROTTLE CONTROL LEVER: •Located on control panel to operator’s right. •Throttle control for engine speed. •Choke fo

ملخص المحتوى في الصفحة رقم 18

OPERATION INSTRUCTIONS The safe and successful operation of the 4000 Series will depend upon the operator having the correct knowledge of all controls used on the mower and making good judgements about the terrain to be mowed. NEVER allow anyone to operate the mower without complete knowledge of all controls and their functions. During initial operation, “learning to drive”, set throttle at slow speed. Sound judgement by the operator will prevent accidents. TOWING: Towing a trailer or other att

ملخص المحتوى في الصفحة رقم 19

OPERATION INSTRUCTIONS BEFORE OPERATING MOWER: 1. Read and observe all safety instructions on your mower and in the manual. 2. Read engine manufacturer’s operating and maintenance instructions. 3. Check engine oil. 4. Check fuel cap to be sure it is in place. 5. Be sure parking brake is on. 6. Mower blade drive is off. 7. Know how to stop engine. (Turn key to off position). 19

ملخص المحتوى في الصفحة رقم 20

OPERATION INSTRUCTIONS TESTING OF SAFETY INTERLOCK SYSTEMS: Do not operate mower if safety switches are not operating properly. PARKING BRAKE SWITCH TEST: a) Place parking brake in OFF position. b) Turn ignition switch to START. ENGINE SHOULD NOT TURN OVER OR ATTEMPT TO START! BLADE DRIVE SWITCH TEST: a) Place parking brake in ON position. b) Engage blade drive switch. c) Turn ignition switch to START. ENGINE SHOULD NOT TURN OVER OR ATTEMPT TO START! SEAT SWITCH TEST: a) In a SAFE AREA away from