ملخص المحتوى في الصفحة رقم 1
Use and Care Guide
®
Liquid Propane Gas Grill
Sears Model No. 122.16648900
Kmart item No. 640-82960819-9
• Parts
• Assembly
• Safety Rules
• Use and Care
• Troubleshooting
Note to Consumer
//_ WARNING:
Read this Owner's manual carefully and be sure your
Leave this Owner's Manual in a convenient place for
gas grill is properly assembled, installed and
future reference.
maintained. Failure to follow these instructions could
result in serious injury and/or property damage. This
Customer Service Hel
ملخص المحتوى في الصفحة رقم 2
//_ WARNING Warranty 2 Combustion by products produced when using Safety Precautions. 2~-4 this product contain chemicals known to the Parts Diagram ......................................... 5 State of California to cause cancer, birth defects, Parts List................................................ 6 or other reproductive harm. Assembly Instructions. .7~9 Lighting Instructions 10-~11 z_ WARNING Light Operation Instruction. 12-13 Failure to comply with these instructions could Cleaning and Ma
ملخص المحتوى في الصفحة رقم 3
• Have your LP gas tank filled by a reputable propane gas dealer and visually inspected and re-qualified at A tankofapproximately 12inchesindiameter by18- each filling. 1/2incheshighisthemaximum sizeLPgastankto • Do not store a spare LP gas tank under or use.YoumustuseanOPDgastankwhichoffers • near this appliance. an Overfill Prevention Device. • Never fill the tank beyond 80 percent full. If this This safety feature prevents the tank from being information is not followed exactly, a fire causin
ملخص المحتوى في الصفحة رقم 4
WARNING A strong gas smell, or the hissing sound of gas indicates a serious problem with your gas grill or the LP gas tank. Failure to immediately follow the steps listed below could result in a fire or explosion that could cause serious bodily injury, , ¸!/ death, or property damage. • Shut off gas supply to the gas grill. • Turn the control knobs to OFF position. • Put out any flame with a proper fire extinguisher. • Open Grill Lid. • Get away from the LP gas tank. Visually check the burner fl
ملخص المحتوى في الصفحة رقم 5
/--02 # 91 _06 O5 5
ملخص المحتوى في الصفحة رقم 6
KEY'#I PARTS DESCRIPTION QUANTITY f_mt'# PARTS DE;SCRJPTION QUANTITY i 6SoA-d0":l' Terr_erature Gauge 1 50 650A_050 Caster 2 2 i 65OA-002 Main Lid screw 2 51 650A:051 side Panel Right .................. i 3 i 650A-003 MainLid _ ...... i'"' '"" 52 650A_052 Back_nel I ] 6SOA-O04 Logo 1 e:_ e50A-053 RiJbber Grom{T_i.................... 2 5...j 650A-005 Main Lid Handle Heel Insulating Spacer 2 54 650A-054 Pew er cord fix bracket 1 6 J"650A-D0'B'Ho'od Bufi'er ............. 2 55 650A-055 Ttansfor_i 1
ملخص المحتوى في الصفحة رقم 7
CAUTION: While it is possible for one person to Figure 2 assemble this grill, obtain assistance from another person when handling some of the larger, heavier pieces 1. Open lid of shipping carton and remove top sheet of cardboard. Lay cardboard sheet on floor and use as a work surface to protect floor and grill parts from scratches. 2. Remove packing materials from shipping carton. 3. You may slice the carton front corners with a utility knife to lay open the carton front panel. This will allow
ملخص المحتوى في الصفحة رقم 8
6. Fromunderside ofleftsideshelf,remove 2screwsand lockwashers to assembly towelrackandbezelsHangthe Figure 9 twotrashclips(R)totherightsideburner shelfedge(Fig.6). 7. Remove (3)1/4x 3/8"Phillips headscrewsand(3)1/4" lockwashers onsideshelffrontpanel. Thenattach front paneltosideshelfusingthesame3screwsandlock washers (Fig.7). 8.Attachleftsideshelfinsamemanner asdescribed for rightsideshelfinsteps2and3. InstallingIgniterModule Locate igniter module at right side of cabinet. Remove silver battery
ملخص المحتوى في الصفحة رقم 9
Installing Cooking Components Figure14 Important: Before cooking on your grill the first time, wash cooking grids and cooking rack with warm, soapy water. Rinse and dry thoroughly. Season with cooking oil regularly. After cooking is completed, turn grill to HIGH setting for 3 to 5 minutes to burn off excess grease or food residue. 1. Install heat diffusers above burners. Holes in rear corners of diffusers attach onto pegs in the back edge of firebox. Ensure that firebox heat shield is inserted s
ملخص المحتوى في الصفحة رقم 10
Checking for LP gas leaks 6. To light additional burners, push and turn burner Never test for leaks with a flame. Prior to first use, at the beginning of each season, or every time your LP knob(s) to;,_ HI or ON and hold in for 3 to 5 seconds dntil burner(s) ignites, then adjust gas tank is changed, you must check for gas leaks. knob(s) to desired setting. 1. Make a 50/50 (soap/water) mild soap solution. 2. Turn the control knobs to full OFF position; then turn gas ON at supply tank. 3. Apply th
ملخص المحتوى في الصفحة رقم 11
If Grill Still Fails To Light Z_ WARNING 1. Check gas supply and connections for leaks. Check Never lean over the grill cooking area while that all wires connections are secure. lighting your gas grill. Keep your face and body a safe distance (at least 18 inches) from the 2. Repeat basic lighting procedure. If your grill still fails cooking grid surface when lighting your grill by to operate, turn the gas off at source, turn the control match. knobs to OFF, then check the following: Manually Lig
ملخص المحتوى في الصفحة رقم 12
1.Make sure the light power switch on the control panel is in the "OFF" position. 2. Connect power plug to properly grounded outlet. 3.Turn the light power switch to "ON." ,/_ WARNING Keep any electrical supply cord away from any heated surface. Halogen Bulb Replacement 1.Make sure that the grill has cooled before changing the light bulb. 2.Make sure the light's power switch on the control panel is in the "OFF" position and power plug is disconnected from the outlet. 3.Use a Phillips screwdriver
ملخص المحتوى في الصفحة رقم 13
Then loosen but do not remove the upper two screws above the light. 7. Pull out the light bulb and replace with a new bulb. Tighten the four screws. Note: Do not touch the halogen bulb with bare hands. 8. Replace glass cover, reinsert light bulb housing into the grill, and insert and tighten the screw. Cleaning Method Follow steps 1 through 4 above for glass cover removal. Use a damp towel to clean the surface of the glass cover. Make sure the glass cover is completely dry before re-installing.
ملخص المحتوى في الصفحة رقم 14
Cleaning Exterior Stainless Steel Surfaces To ensure a proper working unit the following proper care and maintenance is suggested. •Weathering and extreme heat can cause exterior stainless steel surfaces to turn tan in color. Machine Cleaning Cooking Grids oils used in manufacturing process of stainless steel We suggest you wash your cooking grids in a mild soap can also cause this tanning color. Use a stainless and warm water solution. You can use a wash cloth or steel cleaner to polish stainle
ملخص المحتوى في الصفحة رقم 15
3. Inspect each burner for damage (cracks or holes) Regardless of which burner cleaning procedure you and if such damage is found, order and install a new use, we recommend you also complete the following burner. After installation check to ensure that gas steps to help prolong burner life. valve orifices are correctly placed inside the ends of the burner tubes. 1. Use a fiber pad or nylon brush to clean the entire outer surface of each burner until free of food residue and dirt. /'_ WARNING Spi
ملخص المحتوى في الصفحة رقم 16
Indirect Cooking To cook indirectly, the food should be placed on the left or right side of your grill with the burner lit I_. WARNING on the opposite side. Indirect cooking must be Do not leave the grill unattended. done with the Lid down. Your grill will get very hot. Never lean over Flare-ups the cooking area while using your grill. Do not touch cooking surfaces, grill housing. Grill Lid The fats and juices dripping from grilled food can or any other grill parts while the grill is in cause fl
ملخص المحتوى في الصفحة رقم 17
WARNING: To ensure that it is safe to eat, food must be cooked to the minimum internal temperatures listed iinthe table below. USDA* Safe Minimum internal Temperatures Fish 1450 F Pork 160 ° F 160 ° F Egg Dishes 145 ° F Steaks and Roasts of Beef, Veal or Lamb 160 ° F Ground Beef, Veal or Lamb 165 ° F Whole Poult_ (Turkey, Chicken, Duck, etc.) 165 ° F Ground or Pieces Poultry (Chicken Breast, etc.) * United States Department of Agriculture FOOD Weight or thickness Temperature Time Special instruc
ملخص المحتوى في الصفحة رقم 18
Your Home For expe_ troub!eshooting and home solutions advice: ÷ age For repair- in your home - of a!! major brand appliances, _awn and garden equipment, or heating and cooling systems, no ma_er who made it, no ma_er who sold it! For the replacement pa_s, accessories and owner's manuals that you need to do-it-yourself. For Sears professional instaliation of home appliances and items like garage door openers and water heaters. ® R_is_red Trademark _' Tra_mad,: _',, SeP4ce _'Sa_k of Seals B@_ds_ L
